Professional Documents
Culture Documents
ROW QRG FT CT June 2021
ROW QRG FT CT June 2021
ROW QRG FT CT June 2021
FaceTite (FT) and CelluTite (CT) hand pieces are both designed for superficial treatment of the sub-dermis and there
are similarities in their treatment technique. They can be used on their own or as a second stage after NeckTite or
BodyTite deeper treatment. Usually neither applicator requires aspiration following deployment. However, if needed,
CT may be connected to aspirator, and a syringe with a thin spinal needle or thin cannula may be used.
PRE_TREATMENT
• When using FT in the peri-oral region, prophylactic antivirals should be prescribed in all patients with a
history of Herpes Simplex.
• Mark treatment zones while patient is standing. For FT ~6x6cm (2.5x2.5”) zones; For CT ~10x15cm (4-6’’). Mark
with different color pens the pits and elevated nodules of the cellulite.
• Select inferior based access ports for CT, to facilitate drainage, as aspiration is not always needed.
Please Note: Quick Reference Guides are on occasion revised and updated. It is the practitioner’s responsibility 1
to ensure the use of the most current version of the Quick Reference Guide. Current Clinical Updates may be
found on www.InModeResources.com.
QUICK REFERENCE GUIDE (QRG) FaceTite/CelluTite
With single thermistor Date: June 2021
coagulation) or after max. 2sec. In FT you can use the Pulse Mode set at 2sec and release the footswitch if
you hear the popping sound before.
• After covering the full treatment zone with slight overlap of the external electrode, shift to a “fanning”
technique with back and forth continuous, non-stamping movements until the whole area is heated to
cut-off temperature.
• The speed of these movements is slow and methodical, but faster on the face than on the body larger
thermal zones.
• In areas with excessive fibers, such as scars, move slower to facilitate softening and less traumatic
mechanical effects.
• With CT stay within 2cm of the skin surface, treating the 3 structures that cause cellulite:
o Nodules - to be stamped and coagulated with an audible “pop”.
o Pits - to be released completed with the v-dissector at 2-3 levels: 2 and 1 or levels 3, 2, and 1,
until there is no resistance.
o Sub-dermal space heated to 38-40oC by fanning after the stamping performed above.
• With FT treat in one plane only, 3mm into the superficial fat, until endpoint of the cut-off temperature is
reached, or erythema, whichever comes first.
• After reaching the end-point, continue treating for 1-2min and then move on to the next zone.
• Always stop when there is excessive response, cool the area and avoid heating that area further.
• Typically, for FT 1-5kJ is introduced into a full face, and 6-12KJ into the neck area. Small facial areas like
the lower eyelid may require 0.1-0.2kJ, whereas larger areas like jaw line may need 1-2kJ. Typical energy
for a treatment zone with CT is up to 6kJ. It is not recommended to exceed these values for safety reasons.
POST_TREATMENT
• Immediate cooling of the skin can reduce discomfort and excessive skin response.
• Suture access ports that are not in the hair line or under the lobule for FT treatment.
• For CT, if there is not a synchronous aspiration, leave the incisions open.
• Draining of fluids out the incision ports may continue for 1-2 days and dressing should be changed daily.
• Discomfort can be reduced by the prescription of oral analgesia.
• Prophylactic oral and topical antibiotics for the incision ports may be prescribed as per the physician
discretion. It may start the day of treatment and continued for 5-7 days to minimize the risk of infection.
• Garmenting is not necessary after FT treatment. For CT treatment 4 weeks 22/24 hours a day is
recommended. When CT follows BodyTite treatment, then the BodyTite regimen of garmenting should be
applied (3 full weeks and 3 half day weeks).
• Ecchymosis may last for 7-10 days or more.
• Substantial edema may last for 1-3 weeks.
• Decreased or absent sensation may be present in the treated areas and will be gradually regained after
4- 16 weeks or occasionally longer.
RESULTS
• You should see significant edema and a “lift”, “tightening” or contouring effect from the edema and
immediate collagen shrinkage in both applications. Improvement of cellulite is seen immediately after CT
treatment, but improves gradually over 3-9 months and is often best after one year.
TIPS
• Cooling measures should be ready.
• Avoid using FT over superficial injected areas with natural fillers, or very fresh Botox. It is better to inject
after FT treatment, but if already there, treatment over deep natural fillers is possible immediately.
o Over superficial natural fillers – wait for ~6 months and
o Over Botox – wait for one week.
o Treatment over synthetic fillers, like silicon, is contraindicated.
• Avoid using CT over areas with synthetic fillers, such as silicone in the buttocks.
Please Note: Quick Reference Guides are on occasion revised and updated. It is the practitioner’s responsibility 2
to ensure the use of the most current version of the Quick Reference Guide. Current Clinical Updates may be
found on www.InModeResources.com.