This checklist contains safety standards for temporary electrical installations at construction sites. It includes requirements such as ensuring connections go through ELCBs/RCCBs, maintaining ELCB/RCCB registers, protecting overhead service conductors from vegetation, only using equipment in good working condition, adequately protecting wiring from accidental damage and pinch points, using rubber mats for panel boards, properly earthing all equipment, and workers using rubber gloves and safety shoes. The checklist asks to verify if each standard is met (Y), not met (N), or not applicable (N/A).
This checklist contains safety standards for temporary electrical installations at construction sites. It includes requirements such as ensuring connections go through ELCBs/RCCBs, maintaining ELCB/RCCB registers, protecting overhead service conductors from vegetation, only using equipment in good working condition, adequately protecting wiring from accidental damage and pinch points, using rubber mats for panel boards, properly earthing all equipment, and workers using rubber gloves and safety shoes. The checklist asks to verify if each standard is met (Y), not met (N), or not applicable (N/A).
This checklist contains safety standards for temporary electrical installations at construction sites. It includes requirements such as ensuring connections go through ELCBs/RCCBs, maintaining ELCB/RCCB registers, protecting overhead service conductors from vegetation, only using equipment in good working condition, adequately protecting wiring from accidental damage and pinch points, using rubber mats for panel boards, properly earthing all equipment, and workers using rubber gloves and safety shoes. The checklist asks to verify if each standard is met (Y), not met (N), or not applicable (N/A).
No . 1 All connection going through ELCB/ RCCB 2 Is ELCB/ RCCB register maintained? 3 Do you ensure that the support of overhead service conductor not through vegetation such as tree? 4 Is the temporary electrical power and lighting installation used for construction, remodelling, maintenance, repair or demolition of building structure? 5 Is the wiring installed with improper joint Is cable routed through overhead / underground? 6 Is the equipment used for temporary wiring in good and working condition? 7 Is any protection from accidental damage and sharp corner for temporary wiring? 8 Is the wiring adequately protected from the door ways or other pinch points? 9 Is rubber Mat using for Panel Board? 10 Is non conducting material used during suspending temporary wiring from the building structure? 11 Is industrial Plug socket using at site? 12 Are all DB in Good Conditioned and weatherproof shade is available?
13 Are all equipment properly earthed? Is integrity of earthing connection
from equipment to earth pit ensured? Is healthiness of earthing pit maintained? 14 Is Electricians using full Rubber hand gloves and safety shoes during work? 15 Is the cable below 25 Sq.mm. joined and covered with IS certified PVC tape? 16 Cable above & inclusive of 25 Sq.mm. Joined by straight through joint? Is the joining kits supplied by M/s Raychem/M-seal etc