Professional Documents
Culture Documents
RCCB Test Form
RCCB Test Form
2012
Date Issued : 2nd February 2012
RECORD OF RCCB TEST
Revision : -
Revision Date : -
Page : 1/2
A. PARTICULARS OF THE INSTALLATION [Please tick (√ ) the relevant boxes and enter details as appropriate]
Project Name
Drawing No./Installation
Address
Block No./Floor
D. TEST RESULTS (Please X where not applicable. Please refer to Page 2 for notes and test procedures)
Circuit Number And Phase
Circuit Reference
Mark S for Socket and L for Lighting. Others (specify)
Number of Points
RCCB Rated Tripping Current, I∆n (mA)
TEST TP X X X X X X X X X X X X
RCCB Test Button
(i)
(Mark T for Trip & NT for No Trip)
½ I Trip
(ii)
(Mark T for Trip & NT for No Trip)
I Trip at 00 (ms) (iii)
RCCB
0
Trip I Trip at 180 (ms) (iii)
Time 5I Trip at 0 0
(ms) (if applicable) (iv)
at 0
5I Trip at 180 (ms) (if applicable) (iv)
RCCB Test Button
(after completion of the above tests) (v)
(Mark T for Trip and NT for No Trip)
RCCB Trip Current Test (Ramp Test) (mA) (vi)
E. COMMENTS BY JKR (IF ANY) AND DEPARTURES FROM SPECIFICATION & REGULATIONS
A. NOTES
1. This Test Form is for RCCB, without time-delayed operation to IEC 61008.
2. This Test Form is to be used for testing a two (2) POLE-RCCBs and NOT applicable for four (4) POLE RCCBs.
4. The RCCB should be tested with the load switch off or the load disconnected from the circuit.