XII Phy Test 1

You might also like

Download as pdf or txt
Download as pdf or txt
You are on page 1of 3

ARMY PUBLIC SCHOOL AND COLLEGE PETARO

Class: XII TEST Series -I Subject: Physics


Max. Time: _hr Total Marks: 65
Name:__________________ Section:_______

SECTION – A (Marks: 1×12=12)


Q.1: Fill the relevant bubble against each question according to curriculum.
Ser Question A B C D A B C D

1. Two charges q1 and F /2 F/4 2F 4F


q2 are placed in
vacuum at a distance d
and force between
them is F. If a medium
of relative permittivity
4 is introduced
between them then
new force will be:
2. Which one of the Vt = 0 Vt =E Vt < E Vt =E-Ir
following is correct
for an open circuit?

3. The temperature Absolute Kelvin Limiting Critical


below which the temperature temperature temperature temperature
resistivity of a
superconductor falls
to zero is called:
4. A charge Q is divided q = Q/4 q = Q/3 q = Q/2 q=Q
into two parts q and
Q-q separated by a
distance R. The force
of Repulsion between
them will be
maximum when:
5. The electric field at a 3*105N 3*103N 9*105N 9*103N
distance of 20cm from
4*10-6c charge is

6. An electric charge q is q/6ὲ q/6ὲa2 q/4 ὲ q/ὲ


placed at the centre of a
cube of side “a”. The
electric flux on its one
side will be
7. When a wire is 16R 4R 2R 0
stretched and its radius
becomes r/2 then the
resistance will be

8. A wire of uniform Doubled Halved Remains the One fourth


cross-section, A length same
L and resistance R is
cut into two parts. The
resistivity of each part
will be
9. The powers of two 1:2 2:1 1:3 3:1
electric bulbs are 100W
and 200W. Which are
connected to power
supply of 220V. The
ratio of resistance of
their filament will be,
10. When potentiometer is high small Ideally zero Very high
used for measurement
of voltage of an
unknown source, the
power consumed in the
unknown source under
null condition is
11. In a Wheatstone bridge 0A 1A Maximum Half of the
method, the bridge is maximum
said to be balanced,
when the current
through the
galvanometer is

12. In order to achieve As long as As short as Very thin. Very thick


high accuracy, the slide possible possible
wire of a potentiometer
should be

Section B (3x11=33)

Q2. Answer all the following short questions. Each question carries equal marks.

Qno1 Electric potential is a constant throw a given region of space.

Is the electric field zero or non-zero in the region?

Qno2 If a point charges q of mass m is released in a non-uniform electric field with field lines
pointing in the same direction it make a ready linear motion?

Qno3 Differentiate between electric potential and electric potential energy also drive
relationship between them.
Qno4 How can electric potential be high when the electric potential energy relatively low?

Qno5 Can different equipotential lines cross each other?

Qno7 Voltages are always measured between two points why?

Qno6 while analysing a circuit the internal resistance of EMF sources ignored why?

Qno8 Two positive charges of 15*10-10 and 13* 10-10 are placed 12cm apart. Find the work
done in bringing the two charges 4 cm closer?

Qno9; What will happen if a voltmeter is connected in series with the load and ammeter in
parallel with the supply?

Qno10 How can you identify that which plate of capacitor is positively charged discuss
briefly?

Qno11; How do you know about working of Faraday cafe?

Qno12; What are the conditions under which Gausses law applicable?

Section C (5×4=20 )
Note: Attempt all questions

Qno1: Calculate the electric potential when positive charge q taken from infinity to point B with
uniform velocity?
Qno2: Derive an expression for electric field intensity between two oppositely charged parallel plates
at a distance d?
Qno3: Define in any closed circuit the algebraic sum of all voltage sources and voltage drops across
resistors are equal to zero explain in detail with diagram?
Qno4: Define the condition for which the maximum power output we will get from a circuit explain
and drive the relation?

You might also like