Professional Documents
Culture Documents
AOS 8.3.4 ReleaseNotesRevA
AOS 8.3.4 ReleaseNotesRevA
(Note: (1) 11ac Wave 2 products are XA4-240, XD2-240 & XD4-240 plus the XI-AC3470)
32480 Prevent APs with Kingston eMMC from downgrading below 8.3.3, where support for it was introduced.
Rev C Page 1
Xirrus AOS
Version 8.3.4-7092 MAINLINE
Release Notes
Internal-Radius and Active Directory did not start after a reboot. If the Internal Radius SSID is disabled
20276
and you then reboot, Active Directory will start.
20296 Rogue AP – 11ac Wave 1 Radios are seeing rogue APs at higher RSSI levels than 11n radios.
Standby Mode – Enabling standby mode on an SSID could cause a General Error. It is not
25558
recommended to use this feature with this release.
In noisy environments, clients may be slow connecting to 80MHz bonded channels. A workaround is to
25764
avoid using 80 MHz channels in noisy environments.
Admin RADIUS is not working with IPv6 when logging on to the Web Management Interface or the
26045
Command Line Interface
26222 No RADIUS packets are sent to server from PEAP client when primary server is using IPv6.
Attempting to login to AP using IPv6 address via Admin RADIUS with WMI does not work and causes
26300
WPA Authentication Engine restart. Workaround would be to avoid Admin RADIUS logons with IPv6.
L3 Roaming – Layer 3 roaming using Spectralink 8440 and WPA2-PSK is not working. However, L3
26635
roaming works properly with WPA2 Enterprise.
Radio assurance feature is not functional on 802.11ac Wave 2(1) products. Please refrain from using
27041
this feature.
Loss of IP connectivity on 11ac Wave 2(1) radios after a station associates to TKIP encryption only.
27310
Changing the encryption to AES works.
WPR SSL Redirect - Chrome does not allow the user to accept the SSL Certificate. Use alternative
27376
browsers such as Safari or Internet Explorer.
Upstream traffic on the same clients is, in general, slower on 802.11ac Wave 1 APs than it is on
27800
802.11ac Wave 2(1) APs – this has been observed infrequently on Intel 7625-based client chipsets.
On 11ac Wave 2(1) APs, the QoS UP bit in QoS Control Field is always set to whatever QoS setting is
28104
set on the SSID.
Occasionally during boot-up AP sends out a couple of XRP packets with the default IP address of
28489
192.168.1.3. Administrators can safely ignore this debugging message.
29675 An Application Control deny filter for the application hotspot shield is unable to block the app traffic.
Wave 2(1)-capable APs sometimes show incorrect RSSI, SNR and Silence values when a station is first
29831
detected. This problem goes away and can be safely ignored.
Rev C Page 2
Xirrus AOS
Version 8.3.4-7092 MAINLINE
Release Notes
The Console timeout value is not respected. Workaround is to set the XirCon timeout and the Console
26606
timeout to the same value. Working as designed.
Packet Counts for a DNS redirect filter may sometimes be less than the actual number of DNS packets
28675
modified.
29454 Deleting/Adding over 500 MAC addresses in Security/Access Control will give an error.
Bonjour – AppleTV is not able to service a client on SSID with VLAN when AppleTV is on the Bridged
wired network. It is not recommended that you place AppleTV on the Bridged Management LAN
30392 segment. This will cause a lot of multicast traffic to be processed by the Array on the Management
VLAN and can affect performance of the Array. Isolation of Multicast Traffic is recommended to be
handled in VLAN’s that are not part of the Array Management VLAN.
Arrays with large numbers of VLANs (12 – 16+) may occasionally experience the log message
“Process Restart Required: WPA Authentication Engine, restarting process” which indicates that the
30513
ability of clients to associate using WPA is being affected. The recommended workaround is to reduce
the number of VLANs.
Active Directory will not join Domain when Remote Recovery is enabled and flash is disabled. When
31749
you disable flash, - Active Directory, Internal RADIUS, SNMP & HTTP proxy will not run.
Tx Rx
Model Streams Tx power per radio
Chains Chains
Rev C Page 3
Xirrus AOS
Version 8.3.4-7092 MAINLINE
Release Notes
Tx Rx
Model Streams Tx power per radio
Chains Chains
• The table below summarize power requirements and configurations for installing XI-AC3470 radios in an XR
modular AP.
Wave 2 Radio Module Upgrade Configurations
# Radios
Model Upgraded Which Slots to Use (RF
after Watts / Injector Models
Series Model No Slot #s)
Upgrade
30W, PoE+
XR-2000 XR-2247 2 0, 2 XP1-MSI-30, XP1-MSI-75M, XP8-MSI-
70M, XT-5024/5048
40W
XR-2000 XR-2447 4 All slots XP8-MSI-70M,
XP1-MSI-75/75M
75W
XR-4000 XR-4447 4 1, 3, 5, 7 XP8-MSI-70M,
XP1-MSI-75/75M
75W
XR-4000 XR-4847 8 All slots
XP1-MSI-75/75M
95W
XR-6000 XR-6847 8 0, 2, 4, 6, 8, 10, 12,14
XP2-MSI-95M (one port)
0, 1, 2, 4, 5, 6, 8, 9,10, 95W
XR-7000 XR-7247 12
12,13,14 XP2-MSI-95M (two ports)
95W
XR-7000 XR-7647 16 All Slots
XP2-MSI-95M (two ports)
Rev C Page 4
Xirrus AOS
Version 8.3.4-7092 MAINLINE
Release Notes
Rev C Page 5