Nov-2023-Psad-22-Dela-Cruz - Done

You might also like

Download as pdf or txt
Download as pdf or txt
You are on page 1of 2

REVIEW INNOVATIONS

NOV 2023 CE BOARD EXAM REFRESHER (JFDC) PSAD – 22


INSTRUCTION: Select the correct answer for 4. Determine the factored uniform load on
each of the following questions. Mark only beam GHI, in kN/m.
one answer for each item by shading the box A. 36.96 C. 30.91
corresponding to the letter of your choice B. 38.11 D. 29.76
on the answer sheet provided. STRICTLY NO
ERASURES ALLOWED. GOOD LUCK. 5. Determine the maximum factored shear
(in kN) in beam GHI assuming G and I
NOTE: A times B is represented by A×B or are fixed, and H is a roller.
A*B. A raised to the power n is A. 110.88 C. 92.73
expressed as A^n. All problems are 1 B. 114.33 D. 89.28
point each.
6. Determine the maximum factored
Situation 1. The truss is subjected to a positive moment (in kN-m) in beam GHI
highway load of 𝑷𝟏 = 𝟑𝟓. 𝟔 𝒌𝑵 and 𝑷𝟐 = assuming G and I are fixed, and H is a
𝟏𝟒𝟐. 𝟒 𝒌𝑵 with a distance apart of 4.3m. roller.
A. 57.17 C. 55.44
B. 46.37 D. 44.64

Situation 3. A 6m long beam is supported by


a roller at the right end and a fixed
support at the left end. It carries a
uniform load “w” kN/m throughout the
beam.

7. Compute the safe value of “w” kN/m so


that it will not exceed the flexural
capacity of the beam of 270 kN-m.
1. Determine the maximum ordinate for
A. 60 C. 86
member GH.
B. 36 D. 15
A. 1.00 C. 0.50
B. 0.75 D. 0.25
8. Compute the safe load “w” kN/m so that
it will not exceed the shear capacity
2. Determine the maximum reaction in the
of the beam of 180 kN.
truss.
A. 80 C. 48
A. 160.00 kN C. 172.91 kN
B. 24 D. 40
B. 165.24 kN D. 129.45 kN
9. Compute the safe value of “w” kN/m so
3. Determine the maximum response of
that it will not exceed the allowable
member GH due to the loadings.
deflection of 3mm.
A. 142.91 C. 152.49
Consider EI= 432 x 10^12 Nmm^2
B. 165.33 D. 120.74
A. 185 C. 124
B. 76 D. 80
Situation 2. Reinforced concrete beams
having a cross section of 400 x 600 mm
Situation 4. A truck with axle loads of
are spaced 2.5 meters on centers as
19.6 and 67.8 on a wheelbase of d =
shown. These beams support a 100 mm
4.3m rolls across the beam shown in
thick slab. The superimposed loads on
the figure. Determine the following:
these beams are as follows:
Dead load = 3.2 kPa
Live load = 3.6 kPa
The columns E and H are omitted such
that the girder BEHK supports the
beams DEF at E and GHI at H. Assume EI
= constant for all beams. Use unit
weight of Concrete = 24 kN/m^3.

10. The maximum positive moment that can


be developed in the beam.
A. 498.87 kN-m C. 382.66 kN-m
B. 504.92 kN-m D. 452.12 kN-m

11. The maximum negative moment that can


be developed in the beam.
A. – 203.4 kN-m C. – 262.2 kN-m
B. – 58.8 kN-m D. – 129.7 kN-m

12. The maximum reaction at the left


support.
A. 84.03 kN C. 92.16 kN
B. 94.52 kN D. 65.90 kN

Manila/Cebu: https://www.facebook.com/ReviewInnovationsOfficial Davao: https://www.facebook.com/reviewinnovations.davaobranch


NOV 2023 CE BOARD EXAM REFRESHER (JFDC) PSAD 22
Situation 5. A three-story building has
interior columns spaced 8m apart in
two perpendicular directions. The
design loads for the building are as
follows:

DL: 5.0 kPa (Roof)


7.0 kPa (typical for each floor)

LL: 0 (Roof Deck)


6.0 kPa (2nd Floor)
2.4 kPa (3rd Floor)

Recognizing that the probability of


supporting a large fully loaded
tributary area is small, building
codes permit reductions. Use the
attached alternate floor live load
reduction provisions.

13. What is the total axial load (kN) on


an interior column at the second-floor
level due to service LL?
A. 153.6 C. 76.3
B. 164.5 D. 82.3

14. What is the total axial load (kN) on


an interior column at the ground floor
level due to service LL?
A. 287.9 C. 246.8
B. 466.3 D. 288.3

15. What is the total axial dead load (kN)


on an interior column at the ground
floor level?
A. 1,664 C. 995
B. 768 D. 1216

Note: Live load reduction is not


applicable for floors in places of
public assembly and for live loads
greater than 4.8 kPa. For influence
area Ai, consider all area with live
load that can be reduced, that
influence the column being considered
(area projected above).

Manila/Cebu: https://www.facebook.com/ReviewInnovationsOfficial Davao: https://www.facebook.com/reviewinnovations.davaobranch

You might also like