- Use a special syringe to suck. - Fill in the set quantity of new oil through filling hole (see CHARACTERISTICS AND DATA). 84411 - Screw back plug (1) to the set torque.
- Switch (1) for vertical adjustment of light beam (3)
11 - Checking steering column articulation and (available on the dashboard). linkage - With the cab tilted, act on screw (2) for horizontal Steering control linkage adjustment of light beam (3). - Check that the screws and nuts fixing the clamps to the tie rods have not deteriorated and are tightened to the required torque. - The tie rods must not be damaged and the threaded portion must be integral. Ball joints - Clean the ball joints of the tie rods. - This must be done with dry rags or raw cotton; use no solvents. - Check that the ball joints, in their components, have no points of corrosion with sections of depth greater than 1 mm. In particular, check the sheet metal cover close to the rolled section. - Check the protective casing: it has to be secured to the body and to the pin of the articulation with the split ring and it must not turn. - The casing must be neither deteriorated nor damaged. - Manually crush the protective casings and check that lubricating grease comes out. - Check that the nuts and split pins are not deteriorated.