Eurocargo-Tector-12-26t-Repair-Manual (Dragged)

You might also like

Download as pdf or txt
Download as pdf or txt
You are on page 1of 1

EUROCARGO TECTOR 12-26 t SERVICE PLAN 13

EP2 SERVICE 15 - Checking density of antifreeze in the


engine coolant
14 - Cleaning the radiator shade
Figure 21
Figure 19

84412
84413

Remove any dirt from the radiator shade (1) to let air flow
towards the radiator.
The plug (1) must never be taken out for any reason
! whatsoever.
With the engine warm, the cooling system is in
overpressure, therefore take care when taking off
the cap (2).

EP3 SERVICE Take off the cap (2) and draw off a sample of the coolant from
2 - Changing pneumatic system drier filter the expansion tank (3) with the densimeter 99395858.
Depending on the temperature of the liquid, check the
Figure 20 percentage of antifreeze in the liquid on the scale of the
instrument. The percentage has to be higher than 40% and
must not exceed 50%.
If necessary, restore the percentage of antifreeze, bearing in
mind that the liquid needs to be replaced every 2 years.

For vehicles fitted with an additional heater, the


! percentage of antifreeze must never exceed 50%.

77841 18 - Checking the state of the air-conditioning


system refrigerant
Discharge the pressure of the compressed air system. Should gas be replaced, the quantity must be 1020 ± 20 g.
Unscrew the drier filter (1) and change it; tighten it to the
prescribed torque, checking there is no air leakage when - Replace additional heater fuel filter.
pressure is restored.

Print 603.93.111 Base - February 2003

You might also like