Professional Documents
Culture Documents
Required Marks For Acceptable Bolts
Required Marks For Acceptable Bolts
to shipment. This testing must show that the galvanized nut with the lubricant
provided may be rotated from the snug-tight condition well in excess of the
rotation required for pretensioned installation without stripping. This requirement
applies to both hot-dip and mechanically galvanized fasteners. The above
requirements clearly indicate that:
Notes:
1. XYZ represents the manufacturer’s identification mark.
2. ASTM F1852 twist-off-type tension-control bolt assemblies are
also produced with heavy-hex head that has similar markings.
Figure C-2.1. Required marks for acceptable bolt and nut assemblies.