This document provides specifications for a screw conveyor that will transport soda. It is 7500mm long with a 600mm diameter screw that turns at 25 RPM and has a capacity of 60 tons per hour. The screw and housing are made of steel and the system includes inspection doors, flanges, and is driven by a 9.3 kW geared motor.
This document provides specifications for a screw conveyor that will transport soda. It is 7500mm long with a 600mm diameter screw that turns at 25 RPM and has a capacity of 60 tons per hour. The screw and housing are made of steel and the system includes inspection doors, flanges, and is driven by a 9.3 kW geared motor.
This document provides specifications for a screw conveyor that will transport soda. It is 7500mm long with a 600mm diameter screw that turns at 25 RPM and has a capacity of 60 tons per hour. The screw and housing are made of steel and the system includes inspection doors, flanges, and is driven by a 9.3 kW geared motor.
This document provides specifications for a screw conveyor that will transport soda. It is 7500mm long with a 600mm diameter screw that turns at 25 RPM and has a capacity of 60 tons per hour. The screw and housing are made of steel and the system includes inspection doors, flanges, and is driven by a 9.3 kW geared motor.
1 Material soda 2 Bulk density 1000 kg/m3 3 Particle size 4 Temperature Ambient 5 Inlet to outlet 7500 mm / Lift 0 mm/ 0 deg inclination 6 Capacity 60 TPH Rated & Design 7 Screw Dia 600 mm 8 Screw Pitch 600mm 9 Screw pipe 219 mm, Sc-40, 8.18 mm tk 10 Percentage of filling 30% 11 Speed 25 RPM 12 Motor with 30 % filling 9.3 kw -Geared Motor,IE-2 14 Gear Box NA 15 Gear Box ratio NA 16 Service Factor NA 17 Gear Box make NA 18 Input coupling NA 19 Output Coupling Pin & Bush type 20 Coupling make Elecon/Fenner 21 Screw flight Type Sectional flight-6 mm thick 22 Hard facing 30mm wide, 3 mm thk on carrying side 23 Hard facing hardness 300 -350 BHN 24 Screw Deflection 4.876 25 Trough U type,8 mm thk , IS 2062 26 End plate 8mm thk, IS 2062 27 Cover 3.15 Thk /IS 2062 28 Feed end shaft 100 mm 29 Feed end brg 90 mm 30 Hanger Bearing NA 31 Type NA 32 End seal Gland seal 33 Inspection doors 1 Nos 34 Inlet flange 1 No with 8 mm thick 35 Outlet flange 1 No with 8 mm thick 36 Drive bed provided with ISMC 100 37 Screw supports Provided 38 Surface preparation Manual Brushing Two coats of zinc chromate and two coats of 39 Painting synthetic enamel finish paint-75 microns 40 Safety switch Zero speed switch / Jayashree,Kana