Professional Documents
Culture Documents
100 Watts OTL Amplifier Circuit Using Transistor MJ15003
100 Watts OTL Amplifier Circuit Using Transistor MJ15003
Amplifiers
If you are looking for a 100-watt OTL amplifier circuit for the job a small PA system. For example, the
news spread in the village or the sound system for the conference.
I recommend this circuit. Because the sound is very loud. When compared to other circuits at the
same power.
And more importantly, It is very durable. Because It is OTL amplifier type. So, It does not hurt your
very expensive speakers certainly.
But the speaker may sound a little annoying in the only turn it on.
And It’s easy to find and buy these components replaced easily. Because we use all transistors.
Table of Contents
1) How it works
2.2) Note
3) Related Posts
Read the advantages of it is very much. Let’s see the details on this circuit. You will see that We
increased the efficiency from the 50 watts OTL Amplifier circuit.
In first pair differential transistors. We use MPS9682. Then, the preamplifiers drive, Q3. We use
transistor 2SD357.
For the dual power transistors, we use MJ15003 matched pair with MJ15004. So, they have a full real
wattage to 100 watts absolutely.
In figure next, this circuit we use the DC power supply circuit, 90 volts at 5A.
The AC voltage 62V from the transformer is converted by the Bridge diode rectifier to be DC90V
voltage. Then, pass to the 10,000uF 100V Capacitor to filter to smooth DC voltage.
90V 5A DC Power Supply Circuit
Electrolytic Capacitors
C1,C4: 10uF 50V
C2,C5: 100uF 50V
C3: 47uF 50V
C6: 150pF 63V, Polyester Capacitor
C7: 0.022uF 63V, Polyester Capacitor
Note
I hope that friends many happy with this project. But do not forget about security. Check it carefully.
In Figure 3 is a PCB layout and positioning devices. In creating this project, be sure that the soldering
is completed. The polarity of the diodes, capacitors electrolyzed is correct or not?
Copper PCB layout
For safety, always complete your circuit before attaching your power to the circuit.
You should remove the power transistors before. Then, attach the probe of the voltmeter at a point
between R15, R16.
If you are using a multimeter that is not auto-ranging, set it to the 100V range.
Then, add a power source to this project. The voltage must be between 40V to 50V.
But if wrong of these shows, the circuit will not work correctly.
To check the value of the equipment used to assemble the proper place for it or not.
Once you make sure it, so can be connected to the MJ15003+MJ15004 in the circuit.
However, need to make sure that the installation of transistors on a piece of the heat sink all that is
good. Do not lose, or short-circuit with a cooling strictly prohibited.
Then, the input power into the circuit again.
Measure voltage is equal when does not connect the power transistors. Then Input the signal from
preamplifier tone control or audio CD to hear a sample sound.
Caution! This project needs to use the speaker protection circuit. Otherwise, your speaker may be
damaged.