Exam Date: 24-02-2021
Duration: 3 Hours [09:30
zg D OF TECHNICAL EDUCATION AND TRAK +
STATE BOARD Of ICAL EDUC AINING
: TON (G-18) » C1 9-REGULAR-EE-2021
DIPLOMA PEASE TIE, SEMESTER END EXAM
188M) 6332
302C
DIGITAL ELECTRONICS
Session: FN
AM To 12:30 PM) {Total Marks: 60}
PART-A
1. Answer any TWELVE questions 12X1=12
Instructions:
2. Each question carries ONE mark
What is mean by a parity bit.
What is Gray code.
Define fan-out capcity of a digital IC
Mention input and output voltage levels for practical CMOS gate ?
Define combinational logic circuit. :
Define half adder circuit and write its truth table.
Mention any two applications of De Multiplexer
What is 2 bit digital comparator. !
‘What are the values of boolean expressions A + A’ and AA’ ?
Mention any two applications of multiplexer circuit
List any two applications 6€ D Flipflop
Classify the logic gates.
State the need for a Register.
Classty the registers based on mode of input and output
What is RAM & ROM .
What is volatile memory?
https://www.sbtetonline.com rere17(a).
17(b).
18(a).
18(b).
19/a).
19(b).
20(a).
= 20(b).
21(a).
21(b).
22a).
22(b).
23(a).
* 23(b).
24(a).
24(b).
PART-B
Instructions: 1. Answer any SIX questions 6X3=18
2. Each question carries THREE marks
Convert the gray code 101011 into its binary equivalent.
——- OR—
Draw the logic symbols and truth tables of basic logic gates?
Explain logic levels aitd voltage requirements of TTL atid EMOS ICs,
—-OR—
Compare any 3 parameters of the TTL, CMOS, and ECL logic families
Realize half adder circuit using only NAND gates.
—-OR—
Realize the full - adder using two Half - adders and an OR - gate
Write the truth table of 3X8 decoder circuit.
—- OR—
State the need of tristate:buffer.
Compare various niimber' systems.
—OR—
What steps are involved in avoiding the race around condition.
Write the output expressions and Draw the logic symbols for half adder and
full adder.
—OR—
Write the differences between ROM and RAM.
Write about positive Edge triggering and Negative Edge triggering.
—~-OR—
State the need for a Register
List any three applications for counters and ring counter.
—OR—
Draw the diagram of decade counter and write its function table.
https://www.sbtetonline.com Page No.225(a).
25(b).
26a).
26(b).
27a).
2b).
28(a).
28(b).
29(a).
29(b).
30(a).
30(b).
31(a).
31(b).
32(a).
32(b).
PART-C
Instructions; 1, Answer any SIX questions 6X5 =30
2. Each question carries FIVE marks
a) List the steps to convert a given binary number into Gray code.
b) Convert binary number 111010 into Gray code.
-OR-~
Write the proceduté ta perform binary multiplication? aiid Multiply 10111
by 1101.
Explain the input and output logic signal voltage levels of
OR
Compare TTL,ECL,CMOS Logic families ?
Show that two half adders and an OR gate constitute a full adder.
-OR—
Derive the output expressions of half adder and realize it with basic gates,
Explain the function-of 4x8 decoder and draw its logic igcultiagram
—OR— “ee
Explain the 4X1 multiplexer with logic diagram.
Write different laws in boolean algebra
-OR—
Explain the working of a 4-bit bidirectional shift register with a circuit
diagram hitps://www sbtetonline.com
Draw and Explain the function of 2 bit comparator
-—OR—
raw the timing diggram of Mod-16 synchronous binary, UP counter and
explain the counting'sequence . Bie
Draw the logic diagrams of SR fipflop JK flipflop,D fipflop,TAipflop
—OR—
Explain the circuit of JK flip lop (using S-R flipflops) with truth table JK fip
flop.
Explain the working of basic dynamic MOS RAM cell.
—OR—
Write the classification of memories based on principle of operation, mode of
access, period of storage modes and fabrication technology.
TIL,CMOS ICs?
Page No.3
https://www.sbtetonline.com