Professional Documents
Culture Documents
Roller Cleaned
Roller Cleaned
■ Features ■ Accuracy
form a suitable raceway surface, the combined
assembly can be used as a full-complement bearing
IKO Needle Rollers are made of high carbon chromi- The dimensional accuracy of Needle Rollers conforms which has a large load capacity and a low sectional
um bearing steel. They are rigid and highly accurate to JIS B 1506 (Rolling bearings-Rollers), and is shown height. (See page A44, Design of shaft and housing.)
and are finished to a hardness of 58HRC or more in Table 3. Normally in this case, the radial clearance is made a
(See Table 1.) and a surface roughness of 0.1 μ mRa The selective classification for the mean diameter tol- little larger than that of a bearing with cage and the
or less. erance is shown in Table 4. The selective classifica- circumferential clearance is made to be approximately
These needle rollers are widely used as rolling ele- tion rollers according to Table 4 can be provided as 1/10 of the diameter of needle rollers. When the
ments for bearings, and also as pins and shafts. requested. bearing is used under severe conditions, please con-
Please contact IKO, if Needle Rollers made of stain- tact IKO for further information.
less steel are required.
Table 3 Dimensional accuracy of needle rollers unit: μ m
■ End Shapes
Remark Any measured diameter along the total length of roller
must not be larger than the actual maximum diameter at
the center of roller length by the amount exceeding the
Needle Rollers come in spherical and flat end shapes, values given below.
as shown in Table 2. 0.5 μ m for Class 2
0.8 μ m for Class 3
Please contact IKO, if other shapes are required.
1 μ m for Class 5
C 3 0 〜− 3
B 2 0 〜− 2
B 4 − 2 〜− 4
Shapes B 6 − 4 〜− 6 L
B 8 − 6 〜− 8
B10 − 8 〜− 10
Symbol A F
1N=0.102kgf=0.2248lbs.
L23 1mm=0.03937inch
L24
Needle Rollers
Lw
Dw
Roller dia. 1 − 6mm
Dw Lw Dw Lw Dw Lw
g g g
L25