Professional Documents
Culture Documents
Spark 40
Spark 40
Spark 40
Strip all the components from the Punch 3/4” hole on either side for Take one of your 3ft or 10ft
Randall footswitch. Sand and paint the panel mount RJ45 connector. network cables and cut it in half.
whatever color.. I chose flat black. You may have to open the hole up a One half will be used in the
bit with Dremel tool or file. I also footswitch, the other half will be
used a fitted o-ring so that I could used in the amp later.
have the outside connector flush
with the retaining nut.
PDF for the dimensions on the panel mount RJ45
The Footswitch MODZ
Prep all your momentary foot Populate your newly painted Strip jacket 8”, tin & solder each pair to
switches with lock-tight. footswitch with the switches. each switch, install strain relief.
It shows the old switches with L Solder connections:
Blu/bluwht for 1, Org/orgwht for 2,
Grn/Grnwht for 3, Brn/Brnwht for 4
Screw the cover and base back together.
The footswitch is done.
The Cabinet MODZ
Remove the right speaker Choose your location on the back Now use the backplate as your
plate and trim the coating just over template and trace your cabinet thru-
¾” so that when you use your hole on the back of the cabinet.
paddle bit you don’t tear up the Place back plate aside.
jacket. Remove the back plate and
drill the 3/4” hole.
The Cabinet MODZ
With the backplate removed use Carefully remove the circuit Just to the left of the speaker cable
a 1-1/2” paddle bit to open the board. Be mindful of the pass-thru drill a ½” hole into the
pass-thru hole for the RJ-45 Bluetooth cable and speaker lower cavity. Make sure the wiring
connector cable. Unplug the speaker cable below is out of the way. The new
to allow you to rotate the board pass-thru is for the internal network
out of the way for the next step. cable that will routed and soldered
to the circuit board.
The Cabinet MODZ
Connect the other half of With the connector and Remove the back panel again
the network cable that you cable installed, test fit the and remove the circuit board,
cut in half and feed it thru back panel. disconnect the cable from RJ45
up to the ½ hole to where and set the back panel aside.
the circuit board is
The Amp MODZ
2
1 The Test
Pin 1 – Color w/white stipe Looking down with the back of the amp
facing you, carefully position and secure
Pin 2 – Solid Color
the circuit board. Strip the jacket 8”
off the routed network cable and
solder the assigned pairs to the
appropriate contacts.
The Test MODZ
To completely test the crcuit , With a Digital Multimeter set to To serve as strain-relief, zip tie the
connect pedal with the other Ohms, put you leads on pins 1 pairs, and take 4” piece of electrical
12’ network cable to the rear and 2 for each group of tape to cover the contacts.
RJ45 connector. Do not contacts, and press each
reassemble the amp. appropriate footswitch,
testing all four switches.
The Test MODZ
You’re done!