Professional Documents
Culture Documents
WTP M27
WTP M27
INTRODUCTION
WTP M27 treatment is formulated as a balanced blend of chemicals including molybdate and
nitrite, and is proven over a wide range of plant conditions.
ADVANTAGES
• WTP M27 dosage will be calculated and advised by our local water treatment
chemist
• Suggested dosage is 1% of the system volume to give 200 ppm nitrite (as NO2) and
300 ppm molybdate (as MoO4), a simple testing procedure is available for the control
of WTP M27 to ensure conditions are satisfactory
• Application should be made via a recommended point in the system, e.g. a dosing
pot.
• A Nitrite (WTP TK106) and Molybdate (WTP TK160) test kit can be used for the
control of WTP M27 to ensure conditions are satisfactory.
HANDLING
Please refer to material safety data sheet for detailed handling/storage instructions.
Avoid prolonged contact. Not to be taken internally. Wash thoroughly with water, and for
eyes seek medical attention.
PACKAGING
The above information is believed to be correct but does not purport to be all inclusive and shall be
used only as a guide. The company shall not be held liable for any damage resulting from handling,
contact, mis-use or mis-application of the above product. In all instances the user should satisfy
themselves that this product is suitable for the anticipated application and should carry out suitable and
sufficient risk/COSHH assessments and a method of use statement.