INTERNAL ATTACHMENT TECHNICAL REPORT GUIDE
Title page
Tile ofthe report
‘The name of the university and department
‘The student registration number and name
Period of attachment.
Date of submission,
‘Summary
vvvvy
Give a summary of the whole report including key areas you covered, equipmenvapparatus used and key
knowedge and skills gained. i should be a brief overview of the whole internal attachment. The summary
should be hatf a page (double spaced).
State the heading,
Briefly outline how the intemal attachment was done.
State what was achieved in terms of knowledge and skill gained,
Infer the significance of the internal attachment.
vyyy
‘Do not, write any background information on the areas covered or refer to figures, tables and references in the
report.
Contents
Include a table of content isting all section and subsection headings with page numbers. This gives the
‘structural relationship between, chapter, sections and subsections.
Introduction
Highlight the objectives of the internal attachment and comment on flow of the report, indicating what isto be
covered next.
Body of the report
Give report indicating in details the area attached (e.g. Automotive, installation. ..ele.), machine/equipment
used, knowledge and skill gained. You can make use of subheadings for different sections. Present the
information from your research and design. Use figures and tables to present results. (if there was a specific
project work, it should be discussed under this section too.)
Conclusion
Provide a short summary in logic order summing up the objectives. Indicate the extent to which the objectives
‘were met. Highlight the significance of the intemal attachment. It should be short and precise
Recommendation(s)
Highlight solutions to the challenges you faced. Acknowledge limitations and make recommendations.
References:
Give details of referred published materials used/quoted in the main report body section in APA format. Include
any lectures notes and URL addresses of websites referred to.
Appendices
Attach the materials that were too detailed to be inckided in the main report such as technical drawings, or G-
‘codes and subsequent profiles
lt should adhere to these convections:
> Label each appendix with a numberfetier and title
> List these appendix numberlletter on the Content page under the heading Appendix (Appendices if
‘more than one),
> Refer every appendix by numberfeter ata relevant point in the text