Professional Documents
Culture Documents
SAFETY
SAFETY
1 /Users/tommaunglwin/Downloads/SAFETY.docx
HTET ARKAR MAUNG LWIN, 94981, 1111 3/30/2024
ü replace the casing and check the seals normal airflow obstructed, air that
ü leave you with a checklist of bypasses the filter may carry dirt
information about your boiler’s
safety.
directly into the evaporator coil
We provide several different levels and impair the coil's heat-
absorbing capacity. Replacing a
of service. This table shows you
dirty, clogged filter with a clean
what is included in each level.
one can lower your air
Service level
conditioner's energy consumption
Annual boiler by 5% to 15%.
service For central air conditioners, filters
One
Central heating
Common filter locations are in
Home electrics
Four
2 /Users/tommaunglwin/Downloads/SAFETY.docx
HTET ARKAR MAUNG LWIN, 94981, 1111 3/30/2024
coil every year and clean it as technician will find and fix
necessary. problems in your air conditioning
Outdoor condenser coils can also system.
become very dirty if the outdoor
environment is dusty or if there is The technician will:
foliage nearby. You can easily see ü check for correct amount of
refrigerant
the condenser coil and notice if dirt
ü test for refrigerant leaks using a leak
is collecting on its fins. detector
You should minimize dirt and ü capture any refrigerant that must be
debris near the condenser unit. evacuated from the system, instead
Your dryer vents, falling leaves, of illegally releasing it to the
and lawn mower are all potential atmosphere
ü check for and seal duct leakage in
sources of dirt and debris.
central systems
Cleaning the area around the coil, ü measure airflow through the
removing any debris, and trimming evaporator coil
foliage back at least 2 feet (0.6 ü verify the correct electric control
meters) allow for adequate airflow sequence and make sure that the
around the condenser. heating system and cooling system
cannot operate simultaneously
ü inspect electric terminals, clean and
COIL FINS
tighten connections, and apply a
The aluminium fins on evaporator non-conductive coating if necessary
and condenser coils are easily ü oil motors and check belts for
tightness and wear
bent and can block airflow through ü check the accuracy of the thermostat.
the coil. Air conditioning
wholesalers sell a tool called a "fin
comb" that will comb these fins
back into nearly original condition.
CONDENSATE DRAINS
Occasionally pass a stiff wire
through the unit's drain channels.
Clogged drain channels prevent a
unit from reducing humidity, and
the resulting excess moisture may
discolour walls or carpet.
3 /Users/tommaunglwin/Downloads/SAFETY.docx
HTET ARKAR MAUNG LWIN, 94981, 1111 3/30/2024
4 /Users/tommaunglwin/Downloads/SAFETY.docx