01(a). A simple gas turbine was modified with multiple compressors, multiple intercoolers, multiple reheater and regeneration and inlet outlet pressure to remain constant. a) Does work output increase, decrease or remain same? b) Does efficiency increase, decrease or remain same? c) Does back pressure ratio increase, decrease or remain same? d) Heat rejection increase, decrease or remain same? 01(b). A jet of water having velocity 25m/s and diameter of the stream is 200mm hits a flat plate perpendicularly and water splashing out parallel to the plate. Find force exerted on the plate. 02. A machining material has a yield strength of 500MPa and ultimate strength 560MPa. The material is subjected to a load where stress and strain are proportional and strain is 0.1% and E=200GPa. Determine- a) Shear stress using maximum shear stress theory b) Shear stress using distortion energy theory c) Stress developed when elongation is 0.1% d) Strain energy of the material at proportional limit 03. Both side fixed beam, deflection is given, 20 mm, width b, thickness h. If a force is applied in the midpoint of the beam, then if the width and thickness become twice then what will be the deflection if other parameters remain same. 04. Draw sectional view of this object. Section line should pass through center hole so that it bisects the object.