Professional Documents
Culture Documents
Competence 11, 15-16
Competence 11, 15-16
81 Shell plating that has curvature in two 89 The end joint formed plates in a hull plating
directions and must be heated and hammered to strakes is properly identified as a: Butt Bracket
shape over specially prepared forms is called . Search Seam 90 The form that is measure at the
A. Compound plate line of the moulded beam is called?
B. Furnace plate A. Flare
C. Flat plate B. Freeboard
D. Rolled plate C. Rise of floor
D. Camber
82 Ship's hold compartment portioned off special
to carry water, liquid cargo, or for trim and 91 The greatest breath of the ship, measured to
stability: the inside edges of the shell plating is:
A. Double bottom tanks A. Moulded depth
B. Ship peak tanks B. Moulded draught
C. Vessel quantity tanks C. Moulded breadth
D. Vessel reactive tanks D. Moulded edge
83 Strong slip secured to the main framing of the 92 The hull structural members which run
ship's chain that holds the inboard of an anchor arthwartship on a vessel.
chain: A. Deck beams
A. Senhouse slip B. Girders
B. Bitter end C. Stringer
C. Capstan fit D. Breasthooks
D. Deck gate
93 The inner bottom is the : Tank top Tank base
84 Subtracting the height of the center of gravity Tank shop Tank access seamankowts.net 95 The
corrected for longitudinal free surface effects from part of the ofthe ship construction that is fitted
the height of the longitudinal metacenter of a longitudinally and designed to reduce rolling of the
MODU yields: ship at sea is the .
A. „GM‟ A. bilge keel
B. „GML‟ B. bilge wells
C. „KGL‟ C. bilge strake
D. „KML‟ D. bilge fins
85 Subtracting the height of the center of gravity 96 The part of the vessel that cuts the water
corrected for transverse free surface effects from forward .
the height of the transverse metacenter of a A. Bow
MODU yields: B. Keel
A. „GM‟ C. Prow
B. „GMT‟ D. Stem
C. „KGT‟
D. „KMT‟ 97 The part of the vessel that maintain watertight
integrity by covering the whole vessel structure
together is the________plates.
A. shell
B. main deck
C. hull
D. bilge keel
OIC - EW: COMPETENCE 15 Monitor Compliance 9 Special machinery surveys must be carried out at 17 To be in compliance with U.S. Federal Ballast
with Legislative Requirements prescribed intervals ofyears. Water Management regulations, which of the
A. 1 year following procedures may be followed by an ocean
1 All inspections and repair to be done during dry B. 5 years vessel entering U.S. waters returning from an
docking are in accordance with the . C. 2.5 years international voyage?
A. Rules of the classification society D. 6 years A. Prior to discharging ballast water in U.S.
B. Grade steel certificate waters, the vessel must perform a
C. Rules of the shipyard 10 The construction of vessel made of steel should complete ballast water exchange in an
D. Rules of S.M.E. code have a grade in accordance with the . area no less than 200 nautical miles
A. rules of the classification society from any shoreline.
2 An abandoned vessel in the high seas was found B. rules of the shipyard B. Retain ballast water on board the
to be classed. Where will the owner file a claim for C. grade steel certificate vessel.
recovery of his property? D. rules of S.M.E. code C. Prior to entering U.S. waters, use any
A. Insurance Company Coast Guard approved alternative
B. Classification society 11 The derrating certificate’s maximum months of environmentally sound method of
C. Coast guard validity is .. BWM.
D. Port authorities A. 6 D. All of the above
B. 4
3 As per Coast Guard Regulations (46 CFR Part 58), C. 12 18 Under 46 CFR, all mariners directly involved in
a power driven auxiliary steering gear for a vessel D. 9 a “Serious Marine Incident” are prohibited from
capable of a 12 knot service speed, must be able consuming alcohol until alcohol testing has been
to meet the rudder movement requirements at 12 The Exclusive Economic Zone extends from the performed for.
which of the minimum vessel speeds listed below? baseline of territorial sea ofthe United States A. 2 hours following the incident
A. 6 knots seaward. B. 4 hours following the incident
B. 7 knots A. 53 miles C. 6 hours following the incident
C. 9 knots B. 100 miles D. 8 hours following the incident
D. 12 knots C. 200 miles
D. 300 miles 19 Under the ISM Code, what is an identifiable
4 During remuneration among ship owner, master deviation that poses a serious threat to the safety
and the salvaging vessel, what law to be followed? 13 The International Convention that gave of personnel or a serious risk to the environment
A. Law of ship owner immunity to hospital ships in time of war, and that requires immediate corrective action and
B. Law of master's nationality formulates rules the settlement of international includes the lack of effective and systematic
C. Law of savaging vessel disputes is the .. implementation.
D. Law of ship's registry A. Hague Convention A. Near miss
B. SOLAS Convention B. Major nonconformity
5 How many miles is the economic zone of a C. MARPOL Convention C. Incident report
coastal state? D. Mariners Convention D. Observation
100
200 14 The location used for loading or anchoring 20 What accident situation on a vessel, according
300 situated partly of territorial sea of a coastal state is to 46 CFR, would be considered by the Coast Guard
150 called its . as a “Serious Marine Incident”?
A. roadstead A. An injury to a crew member which
6 In accordance to 46 CFR, a cargo hatch fluid- B. breakwater renders that person unfit to perform
power operating system is considered to be fail- C. economic routine vessel duties and requires
safe if a component failure will result in: D. anchorage area professional medical treatment.
A. continuous operation of the system B. Damage to property in excess of
B. a safety interlock producing a regulated 15 The necessary precautions that the port health $100,000.
shutdown of the system authority must take for a newly arrived ship C. A discharge of 10,000 gallons or more of
C. the guaranteed safe and efficient coming from an infected area. oil into navigable waters of the U.S.
operation of the system at all times A. Quarantine D. All of the above
D. a slow and controlled release of the B. Control of sewage system
loading so as not to endanger personnel C. All crew must be vaccinated 21 What does it means "to monitor and measure
D. All of the above processes and product against policies, objectives
7 In accordance to Coast Guard Regulations (46 and requirements for the product and report the
CFR), on a freight vessel, each fire pump must be 16 The vessel committed an accident while passing results"?
capable of supplying the two highest outlets channel under pilotage. Who is liable for claims? A. Act
simultaneously, at a Pitot tube pressure of: A. The pilot B. Plan
A. 50 psi B. The master C. Check
B. 75 psi C. Ports authority D. Do
C. 125 psi D. Master of the other vessel
D. the pump relief valve setting 22 What is an agreement among States which are
Parties to subject convention?
8 QMS requires that the documents should be . A. International Regulation
A. controlled B. International Law
B. accessible C. International Convention
C. printed D. International Treaty
D. read
23 What is an enforcement by the national 31 Which of the following is considered the objective 39 A load line for a MODU is assigned by the:
administration of the relevant provisions of evaluation of all facts, opinions, statements, physical A. Minerals Management Service
international maritime conventions on foreign ships evidence to reduce the possibility of recurrence? B. Department of Energy
visiting its ports? A. Incident Requirements C. Corps of Engineers
A. Port State implementation B. Incident Conclusion D. a recognized classification society
B. Flag State implementation C. Incident Investigation approved by the Coast Guard
C. Coastal State Implementation D. Incident Recommendation
D. Administration implementation 40 Aboard tankers, the term Category “A” Machinery
32 Which of the following is considered the objective Space means any space including trunks and ducts to
24 What is the objective evaluation of all facts, evaluation of all facts, opinions, statements, physical that space containing:
opinions, statements, physical evidence and related evidence to reduce the possibility of recurrence? A. internal combustion machinery used for
information, as well as defined action steps to reduce A. Incident Requirements main propulsion
the possibility of recurrence? B. Incident Conclusion B. one or more oil fired boilers or oil fuel
A. Incident Requirements C. Incident Investigation units
B. Incident Conclusion D. Incident Recommendation C. internal combustion machinery used for
C. Incident Investigation purposes other than main propulsion
D. Incident Recommendation 33 Which of the following is the reason why where the total collective power is at least
separation bulkhead need to be watertight ? 500 brake horsepower
25 What organization which supervises the A. Class requirement D. all of the above
construction of vessels & during her lifetime sets rules B. To maintain integrity ofthe hull
and standard to maintain vessels seaworthiness? C. Use as safety factor in case of collision 41 According to Coast Guard Regulations (46 CFR), a
A. Classification society D. Conditionally required by class single steel hull cargo vessel operating exclusively in
B. flag state freshwater, shall be dry-docked, or hauled out, at
C. administration 34 Which of the following protection risks are covered intervals not to exceed:
D. port state control by P & I ? A. 1 year
A. Liabilities relating to death, personnel B. 2 years
26 What would be the maximum time delay period injury, wreck removal and pollution C. 3 years
allowed for a ships steering system to reach a 15 B. Liabilities relating to death of a person and D. 5 years
degree right rudder helm order from midships, before injury
an alarm condition will be indicated? C. Relating to wreck removals and pollution 42 All amendments ofthe STCW convention shall be
A. 5 seconds D. Damage to each own ship referred to what body of the organization?
B. 10 seconds A. International Shipping Federation
C. 15 seconds 35 Which of the pressure vessels listed is required B. World Maritime University
D. 20 seconds under Coast Guard Regulations (46 CFR) to be C. Maritime Safety Committee
hydrostatically tested once every three year period? D. International Labour Organization
27 When estimating the cost of collision damage to a A. Tubular heat exchangers
tank vessel after a marine accident, which of the B. Hydraulic accumulators 43 As per 46 CFR Part 61, which of the following
following should NOT be included in the repair cost C. Air receivers with no manholes or other machinery remote control shutdowns is/are required
estimate in accordance to 46 CFR? inspection openings to be tested during each regular inspection for
A. Cost to off-load the current cargo D. Bulk storage tanks for refrigerated certification?
B. Cost to gas-free the cargo tanks liquefied CO2 A. Forced draft fan
C. Cost to dry-dock the vessel B. Induced draft fan
D. All of the above 36 Who is responsible to take measures to ensure that C. Fuel oil transfer pump
there are no unreasonable radiation or other nuclear D. All of the above
28 When the vessel is under bareboat charter and the hazards at sea or in port, to the crew, passenger or
vessel sustained damages, which of the following will public waterways or food or waster resources in 44 As per the ISM Code, in matters of safety and
account for the repair? accordance to regulation on radiation safety? pollution prevention, the commitment, competence,
A. Insurance company A. Administration attitudes and motivation should be the main concern
B. The owners B. Port state control of
C. The agent C. classification society A. individuals at all levels
D. The charterer D. flag state B. top management
C. management level officers
29 Which of the following can be issued by an 37 Who is the person assigned/authorized by law to D. designated person ashore
administration in exceptional necessity to fill a vacant board any vessel to conduct survey or inspection for
post in short period? control, safety & over-all condition of ship? 45 As stipulated in the Coast Guard Regulations (46
A. Certificate A. Marine surveyor CFR), which of the following statements is correct
B. Dispensation B. Port state control officer regarding the steering apparatus requirements for a
C. Provision C. Ships agent vessel over 250 feet in length?
D. Resolution D. Port authority A. Hydraulic structural rudder stops are
mandatory.
30 Which of the following has the authority to 38 With reference to U.S. Coast Guard Regulations (46 B. On hydraulic type steering gears, a suitable
approve if there are alterations to be made on the CFR), a 10 pound dry chemical extinguisher is arrangement of check valves in the main
structure or equipment of the vessel after it has been equivalent to a: piping system may be considered as a
previously surveyed and certificated? A. 1 3/4 gallon foam means of steadying the rudder.
A. Charterer B. 12 gallon foam C. A separate auxiliary means of steering is
B. Administration C. 15 pound CO2 fire extinguisher not required where the main gear is of the
C. Ship owner D. 35 pound CO2 fire extinguisher dual power hydraulic type, having two
D. Management company independent pumps and connections.
D. All of the above.
46 Carrying out of boiler inspection for Philippine flag 54 Under Coast Guard Regulations (46 CFR), a power 62 Which of the following marine insurance policy
vessel is done by . driven auxiliary steering gear for a vessel capable of a covers when damages occurred during collision with
A. Class surveyors 20 knot service speed, must be capable of producing another vessel?
B. Bureau of Customs a specific range of rudder movement at which of the A. Hull
C. Marina minimum speeds listed below? B. Cargo
D. P.C.G A. 7 knots C. Protection and Indemnity
B. 10 knots D. None of these choices
47 For each passenger vessel, according to 46 CFRs C. 15 knots
Part 199, normally operating above 32 degrees north D. 20 knots 63 Which of the following shall mean the State which
latitude, the minimum number of immersion suits to has consented to be bound by the treaty and for
be carried for each lifeboat is at least. 55 What do you call a State which has consented to which the treaty is in force as defined by the United
A. 1 be bound by the treaty whether or not the treaty has Nations Convention on the Law of Treaties?
B. 2 entered into force? A. Administration
C. 3 A. Contracting State B. Party
D. 4 B. Negotiating State C. Port State
C. Third State D. Flag State
48 In accordance with Coast Guard Regulations (46 D. Party
CFR), what quantity of B-II extinguishers would be 64 Who is responsible for vessel’s formalities ?
required in an oil fired boiler space on a 25,000 gross 56 What is an area beyond and adjacent to the A. Ships agent
ton cargo vessel in which no sand, soda impregnated territorial sea ofthe State, which is extended up to 200 B. Owners
sawdust, or other approved dry materials are nautical miles from the baseline from which the C. Port authority
provided? breadth of territorial sea is measured? D. Customs
A. 1 A. Extensive Economic Zone
B. 2 B. Entry to Economic Zone 65 A kind of passage where the freedom of navigation
C. 3 C. Exclusive Economic Zone was exercised solely for the expeditions travel as
D. 4 D. Exclusive Territorial Waters provided in the "United Nation Convention Law of the
Sea".
49 In reference to the Coast Guard Pollution 57 What is traditionally considered as an agreement A. Transit
Prevention Regulations (33 CFR), no person may between a passenger and a maritime carrier by which B. Survey
transfer oil to or from a vessel unless: the latter undertakes, for a fare, to carry a passenger C. Innocent
A. each part of the transfer system not by sea? D. Pilotage
necessary for the transfer operation is A. A contract of passage
securely blanked or shut off B. Bill of lading 66 A vessel is in compliance with federal regulations
B. the discharge containment is in place C. Notice of readiness regarding the discharge of sewage by:
C. each scupper or drain in a discharge D. Dispatch advice A. holding all sewage onboard
containment system is closed B. treating sewage in an approved system
D. all of the above 58 What Philippine government agency is the C. pumping the sewage ashore to an
implementing arm of STCW regarding flag registration approved container
50 It is the UN Convention that govern the basic is concerned? D. all of the above
principle of vessel nationality and is called . A. MARINA
A. 1958 Convention of the high seas B. PCG 67 According to 46 CFR Part 199, on a cargo vessel,fire
B. 1973 MARPOL Convention C. DOTC and boat drills must be held within 24 hours of leaving
C. 1978 STCW Convention D. PPA port if the percentage of the crew replaced is more
D. 1986 UN Convention on registration of than.
ship 59 When is the passage of any ship in any territorial A. 5%
seas considered as Innocent Passage as defined under B. 10%
51 Safety Construction Certificates, Safety Equipment UNCLOS? C. 25%
Certificates, Safety Radio Telegraphy Certificates, A. When the passage is NOT within 12 D. 40%
International Loadline Certificates are statutory nautical miles from the shore line.
certificates issued to vessel under which convention? B. When the passage is NOT involving calling 68 According to Coast Guard Regulations (46 CFR),
A. 1974 SOLAS Convention in a port within the territorial seas of the each fire hydrant must have at least.
B. 1972COLREG Convention coastal State. • one length of fire hose with an approved
C. 1978 MARPOL Convention C. When the passage is NOT prejudicial to the nozzle
D. 1966 Loadline Convention peace, good order, or security of the • a spanner wrench
coastal State. • a hose rack or other device for stowing
D. When the passage is done by a ship of a hose
52 The Federal Water Pollution Control Act requires Flag State which is a Party to the UNLCOS. • all of the above
the person in charge of a vessel to immediately notify
the Coast Guard as soon as he/she knows of any oil 60 Which of the following denotes a voyage from a 69 All mariners, in accordance to 46 CFR’s,directly
discharge. Failure to notify the Coast Guard can lead country to which the present Convention applies to a involved in a “Serious Marine Incident” are required
to a monetary and imprisonment up to: port outside such country? to submit a urine specimen for screening of
A. 5 years A. National voyage dangerous drug use within.
B. 3 years B. Interglobal voyage A. 2 hours
C. 2 years C. International voyage B. 12 hours
D. 1 year D. Domestic voyage C. 24 hours
D. 32 hours
53 The most important of all UN treaties dealing 61 Which of the following is often considered to be
maritime safety is the . the “branch of jurisprudence that governs ships and
A. SOLAS shipping?
B. IMO A. Maritime law
C. IMCO B. International law
D. GMDSS C. Shipping law
D. Admiralty law
70 As per Coast Guard Regulations (46 CFR), pump 79 In reference to Federal Regulations, a confined or 87 What is a government agency of the State which
room ventilation on a U.S. flag tanker may be enclosed space that is being prepared for crew has been vested by the State by virtue of laws to
accomplished by: members to enter, should be tested and designated administer maritime- related affairs as well as enforce
A. steam or air actuated gas ejectors “NOT SAFE FOR WORKERS” if the oxygen content of relevant maritime conventions?
B. power blowers the atmosphere in the compartment is LESS than: A. Port State Administration
C. natural ventilators A. 13.50% B. National Maritime Administration
D. all of the above B. 15.50% (MARINA)
C. 17.50% C. Flag State Administration
71 As provided in the 73/78 MARPOL conventions, D. 19.50% D. Coastal State Administration
what do you call the tank constructed adjacent to the
shell plating of tanker vessels? 80 Is the service of pilot necessary for docking and 88 What is P & I Insurance?
A. Deep tank undocking of vessels within Phils. Ports? A. Total Cargo Loss Insurance
B. Wing tank A. Required B. Basically a Third Party Liability Insurance
C. Slop tank B. Not required C. Life Insurance
D. Sludge tank C. Mandatory and required D. Accident Insurance
D. It depends to the master
72 Based on Coast Guard Regulations (33 CFR), a 89 What would be the minimum distance from any
“suspension order” to suspend oil transfer operations shoreline that a vessel must be located before it is
can be withdrawn by the appropriate: 81 Responsible to ensure that all records required by permitted to perform a complete ballast water
A. Captain of the Port regulations are retained onboard a vessel involved in exchange to be in compliance with U.S. Federal Ballast
B. Officer-In-Charge, Marine Inspection casualty is the: Water Management Regulations?
C. District Commander A. Officer - in - charge, Marine Inspection A. 12 nautical miles
D. all of the above B. Owner B. 50 nautical miles
C. Engineer C. 100 nautical miles
73 Coast Guard Regulations 46 CFR, stipulate that in D. Fire man D. 200 nautical miles
addition to emergency signals, muster lists must
specify: 82 The construction of vessel of hull made of steel 90 Which of the following agencies of the United
A. actions to be taken by persons on board should have a grade in accordance with the . Nations tasked to develop international legislation
when each signal is sounded A. Rules of the classification society concerning safety & marine pollution prevention?
B. the order to abandon the vessel B. Rules of shipyard A. ILO
C. the duties assigned to different members C. Grade steel certificate B. IMO
of the crew D. Rules of S.M.E.C. C. UNCTAD
D. all of the above D. MARINA
83 The documents containing particulars relating to
74 How many nautical miles is the breadth of the terms of agreement between the master of the 91 Which of the following has the rights to maintain a
territorial sea of coastal state? vessel and the crew are called . register of ships and assume jurisdiction under its
A. 12 A. Contract of Affreightment domestic law over each ship flying its flag and its
B. 24 B. Notice of Readiness masters, officers and crew?
C. 50 C. Shipping Articles A. Port State
D. 100 D. Assignment Clause B. Flag State
C. Coastal State
75 IMO was established to adopt legislation while the 84 The International Loadline Certificate shall be D. Administration
signatory governments are responsible for its . issued to .
A. implementation A. vessel whose country is a signatory to the 92 Which of the following maybe done by a coastal
B. seafarers deployment convention State for the purpose of ascertaining that the State
C. deregulation B. vessel surveyed and covered by laws relating to exploitation and conservation of
D. training convention marine resources within its EEZ are not violated?
C. only ships registered in the Philippines A. Interdiction in the management of the
76 In accordance to 46 CFR’s, a fixed foam system D. vessel built by an accredited shipyard foreign ship
aboard a tank vessel constructed in 1968, must be B. Confiscate the foreign ship and its cargo
designed to supply foam for a minimum of: 85 The objectives of the international safety C. Fire upon the foreign ship
A. 3 minutes management code to be learned by all crew onboard D. Board the foreign ship
B. 7 minutes are : I - safety of life and property II - safe vessel
C. 12 minutes operation III - safe and clean environment 93 Who is the entity authorized by the International
D. 15 minutes A. I and II law to board the vessel first upon arrival from other
B. I and III country?
77 In accordance with Coast Guard Regulations (33 C. II and III A. Quarantine
CFR), each pressure gage used in fuel transfer D. I, II and III B. Immigration
operations must be calibrated to indicate pressure C. Customs
within what percent of the actual pressure? 86 This is issued to master, officers and ratings who D. Pilot
A. 3% meet the requirements, qualifications and
B. 5% examination in accordance to the STCW convention
C. 7% and is called .
D. 10% A. Dispensation
B. Certificate
78 The certificate which has the shortest validity is the C. Provision
. D. Endorsement
A. derrating
B. radiotelegraphy
C. radiotelephony
D. inoculation
OIC - EW: COMPETENCE 16 Application of 8 Which of the following is the most ideal in 16 What is this process in risk assessment that
Leadership and Team Working Skills maintaining behavioral working group? determines what can go wrong?
A. Same age bracket A. Pro-active approach
1 Under the ISM Code, what is a document issued B. Same gender B. Reactive approach
to a ship which signifies that the Company and its C. Same perspective C. Active approach
shipboard management operate in accordance D. Same nationality D. Risk-based approach
with the approved safety management system?
A. Safety Management Certificate 9 According to the ISM Code, it means a structured 17 Which of the following is intended to cultivate
B. Document of Compliance and documented system enabling Company a safety culture in the whole cabin of ship
C. Class Certificate personnel to implement effectively the Company operation?
D. Documentation Certificate safety and environmental protection policy. A. ISPS Code
A. QMS B. Port state control
2 What does the quality manual need to have? B. ISO C. ISM Code
A. The documented procedures C. SMS D. PMMRR 97
established for the QMS D. FMEA
B. The effectivity of the QMS 18 Who is responsible to the Operation Manager
C. The versions of the applicable 10 How do we manage risks, currently and for the technical aspects and seaworthiness of the
documents of the QMS predominantly on board ships? ships, except for the engineering spaces and
D. The complexity of the processes A. Through the documented Quality personnel?
Management System A. Marine Superintendent
3 What is done to ensure that QMS is suitable, B. Through the documented standard B. Master
adequate and effective? operating procedures C. Designated Person Ashore
A. Internal communication C. Through the documented Safety D. Fleet manager
B. Management review Management System
C. Provision of resources D. Through instructions manual 19 As per the ISM Code, what is a statement of fact
D. Quality policy made during a safety management audit and
11 In the ISM Code, what is an observed situation substantiated by objective evidence?
4 What is the purpose of risk assessment? where objective evidence indicates the A. Non-conformance
A. To ensure that every risk and incident on nonfulfillment of a specified requirement? B. Near miss
board are duly assessed and A. Non-conformity C. Observation
investigated and reports are made for B. Near miss D. Incident report
the management C. Incident report
B. To ensure that careful examination of D. Observation 20 How do you treat the documents required by
shipboard operations are carried out to the QMS?
determine what can cause harm, that 12 The ISM Code means . It shall be controlled
existing controls are adequate and A. International safety management for It shall be printed
determine if risk level are tolerable the safe operation of the ships It shall be justified
C. To ensure that every risk and incident on B. International security management for It shall be compiled
board are duly assessed and the safe operation of the ships
investigated C. Internal safety management for the safe 21 The ISM Code for safety management is one of
D. To ensure that no incident happens on operation of the ships the tools for implementing a risk-based approach.
board D. International safety management for The management system therefore should .
the secure operation of the ships A. establish procedures for abandon ship
5 Which of the following "documented B. establish safeguards against all
procedures" is NOT required under ISO 13 Who shall provide evidence of its commitment identified risks
9001:2000? to the development and implementation of the C. establish procedures for oil spill drills
A. Preventive actions QMS and continually improving its effectiveness? D. establish procedures for incident
B. Corrective actions A. Designated Person investigation
C. External audits B. Owners
D. Internal audits C. Master of the vessel 22 The manner of establishing objectives and
D. Top management processes necessary to deliver results in
6 Which of the following is NOT a concern of the accordance with customer requirements and the
ISM Code? 14 What do you call that declaration by master organization's policies is called planning
A. Safety at sea regarding the cause of damage beyond his control? instructing checking acting 23 What is a document
B. Prevention of human injury A. marine protest issued to a Company which complies with the
C. Avoidance of damaqge to life and B. damage report requirements of the ISM Code?
property C. force majeure A. Safety Management
D. Medical examination D. declaration of protest B. Certificate Document of Compliance
C. Certificate of Documentation
7 Which of the following is one of the quality 15 What is a source or a situation with a D. Certificate of Competence
management principles? potentialfor harm in terms of human injury or
A. Pricing damage to property, damage to the environment, 24 What is required of the quality policy?
B. Quality policy or a combination of these? A. It must be measurable and consistent.
C. Systematic approach to management A. Event B. It must be memorized by all members of
D. Control measures B. Incident the organization.
C. Accident C. It must be generic.
D. Hazard D. It must be appropriate to the purpose of
the organization.
25 What is the basis of competence of personnel 33 What does a “Ship’s Certificate of Registry”
performing work under QMS? indicates?
A. Education, training, skills and A. Evidence of the nationality of the ship
experience B. Issued by Maritime Industry Authority
B. Experience, conformity, simulation and in case of Philippine Flag Ships
environment C. A document serving as title or deed or
C. Mission-orientation, dependability, ownership ofthe vessel
certification and efficiency D. Only Filipino citizens can be employed
D. Effectiveness, training, cleanliness and to man the ship
risk management