CAR

Part 2 of CA form 6 is:

General
CAR -145 compliance audit review

Compliance with MOE

Findings car-145 compliance status

Phase 1 training given to the person to start work without supervision in FTS ( Fuel Tank Safety
Training)

after 3 months joining the organization

not later than 6 months after joining the organization

after 6 months joining the organization

after 12 months joining the organization

All delays to scheduled service of 15 minutes duration or more on account of aircraft defect shall
be reported to

QCM
DGCA

RAWO

Not required to be reported

IAR 60 (2) authorise DGCA to:

 Specify the standard of balloons maintenance
Specify the standard of glider maintenance

Specify the standard of aircraft maintenance

None of the above

Computer system should have atleast one back up system, that should be updated within:-

36 months
72 hours

24 hours

48 hours

MEL shall be prepared by

MEL shall be prepared for all aircrafts where the aircraft manufacturer issued MMEL
Other operators operational experience for similar type of aircraft

Under the provision of Rule 133A

All are correct

For approval of organisation, one have to apply on:-

CA Form-4
CA Form-6

CA Form-2

CA Form-45

What part of the eye controls the amount of light that is allowed to enter the eye?.

The pupil.
 The iris.

The cornea.

Lens

Amendments to MEL based on revised MMEL shall be approved by

RAWO/Sub RAWO
DGCA

QCM

Manufacturer

SMS ( Safety Management System) shall contain proactive and reactive

Quality assurance
Individual performance

Facility, equipment, document and procedure

NOTA

Task / Work carried out to ensure continued airworthiness of aircraft

Servicing
Inspection

Overhaul

Maintenance

Scope of approval in case of CAR MApproved Organization is reflected in

Maintenance manual
Quality control manual
 Exposition

All Are correct

MTCS

Temporary C Of R for purpose of bringing the aircraft by air

Valid till first landing at custom aerodrome in India

Both (

Tem c of r is valid for 1yr

Aircraft Technical Log is preserved for:-

12 Months
36 Months

36 months after the date of last entry

24 Months

The incident where a 737 lost oil from both engines is a direct result of.

poor design.
human error.

engine vibration.

NOTA

The nationality and registration mark should be affixed on the aircraft in accordance with

Rule 5
Rule 37

Rule 30
 Rule 15

The applicable maintenance data is

any applicable requirement, procedure, standard or information issued by DGCA,

any applicable airworthiness directive,

applicable instructions for continuing airworthiness, issued by type certificate holders

Storage condition for components must be in accordance with the instruction issued by

DGCA
Manufacture

Both

None

Mandatory modifications/inspections are to be complied with:-

Immediately on receipt
Within the stipulated period

Within 3 months

Within 6 months

AAC 1 of 2017 stands for:-

Modification & Repair

NDT

Emergency Equipment & Instrument

Maintenance of Test Equipment

How long is the short term memory good for remembering 7 items?.

30 to 60 seconds.
Up to 30 seconds.

Above 60 seconds.

NOTA

Minor amendments of CAME are submitted to

DGCA headquarter at least 15 days before their affectivity

DGCA local office at least 30 days before their affectivity

RAO at least 15 days before their affectivity

DGCA local office at least 15 days before their affectivity

What causes the most aircraft accidents?.

Communication
Technical Faults

Misunderstanding between ATC and pilot on approach.

Strict regulations by airworthiness authority.

CA Form for type certificate

CA-30
CA-28

CA-35

CA-33
Minimum age for certifying staff is:-

21 years
20 years

18 years

23 years

Restoring an aircraft unit to it original design performance level after replacing/re-working parts
to a given standard is termed as:

Maintenance
Overhaul

Top overhaul

None of the above

The scientific study of measurements of the human body is known as.

ergonomics.
physiology.

anthropometrics.

Psychology

Operator shall mention in his __ manual as to when and where MEL item will be attended to

Quality control manual

Aircraft maintenance manual

Maintenance system manual

Quality assurance manual

What part of the SHEL model would the writing and interpretation of maintenance manuals fit
into?.

Hardware.
Software.

Environment.

Live ware

For A/C component maintenance, there should be

Hanger
Suitable workshop

Both (

Modification and repairs are covered in:-

IAR 55
IAR 50

IAR 52

IAR 49

Approval recommendation report is given on form

CA form 2
CA form 4

CA form 6

CA form 8
Which section of aircraft technical log contains details of next maintenance schedule

Section 1
Section 2

Section 3

Section 4

Which rule of aircraft rules 1937 lays that a major defect or major damage to an a/c registered in
India Shall be reported to DGCA:

Rule 53
Rule 55

Rule 59

Rule 60

Consumption of alcohol:-

Increases mental and physical reaction times

Decreases mental and physical reaction times

Has no effect upon mental and physical reaction times

Decreases mental but increases physical reaction times

Peripheral vision is detected by the.

cones.
fovea.

rods

Visual cortex.
ICAO convention held on:-

7 December 1937
16 November 2001

7 December 1944

16 November 2000

Computer system should have at least one back up system& should be updated within

24 hours
72 hours

36 hours

48 hours

CA form 2 is used as an application for

Issue of an approval
variation of approval

Renewal of approval

All are correct

MEL shall include

Cat. A
Cat. A + B

Cat. A+B+C

Cat. A+B+C+D
An engineer is working on a wing and kicks a spanner off into an engine cowl and breaks a
sensor. This is

knowledge based error.

skill based error.

based error.

NOTA

An organisation is said to have good human factors practice if the shift handover overlapping
period is:-

5 to 10 minutes
10 to 20 minutes

20 to 30 minutes

Around 1 hour

Log book entry should be made within;

48 hours
72 hours

24 hours

120 hours

Myopia is _______ and a ______ lens is needed to correct it.

long sightedness and concave.

short sightedness and convex.

short sightedness and concave

long sightedness and convex

Taxi permit:-

Issued by RAO
issued by DGCA

Issued & renewed by RAO / SRAO

issued & Renewed by QCM

What part of the SHEL model would the aircraft design fit into?.

Liveware.
b)Hardware.

Environment.

Software

On a task that is complex, an engineer uses his own procedure due to pressure, this is legally
termed:-

Modification
Initiative

Violation

Slip

Maintenance man hour should be reviewed and updated every

Month
Three months

Quarterly

Six months
During test flight incident and accident occurred will report to

DGCA
Quality Department

RAO

Owner of the Aircraft

MEL is prepared by

Operator
AME

operational person

Flying Officer

The safety policy shall be signed by whom

Service provider
Accountable executive

Operator

Accountable Manager

Use of photographic flash equipment during refueling :

Not permitted to be used with in 6 m

Not permitted to be used within 15 m

Not permitted to be used within 6 m from refueling equipment / vent/ refueling point

Not permitted to be used within 6 ft from the refueling point

The credential of nominated person are forwarded to DGCA in

CA form 2
CA form3

CA form 4

CA form 6

Most engineering related incidents are due to.

installing dirty connectors.

installing components incorrectly.

installing worn or oldcomponent.

Installing unapproved component.

Aircraft Fuel Tank Safety (FTS), continuation training should be carried out:-

3 Months
Each 2 Year period

After 5 Years

Every Month

Which part of SHEL model is most difficult to protect from errors by 'designing out' or to 'work
around?

Liveware
Software

Hardware

Environment
Items not included in MEL

Wings, complete engines

One engine failure

Galley equipment

All above

Risk assessment and management is.

reduction of risks to a tolerable standard and monitoring the situation.

the investigation of risks and totally removing them and the monitoring of new work practices.

choosing a cheaper supplier or manufacturer for parts

reduction of risks to a tolerable Standard only

Weight and balance sheet retained in:-

QC Manual
Maintenance Manual

Maintenance Data

Weight & Balance Manual

Learning of a routine by repeated practice is known as.

Motor programming.
Cognitive learning.

episodic memory.

Echoic memory.
The difference between a mistake and a violation is.

a mistake is less serious than a violation.

a violation is not deliberate.

a violation is unintentional and a mistake is deliberate

a mistake is unintentional and a violation is deliberate

During test flight incident and accident occurred will report to

DGCA
Quality department

RAO

Owner of the Aircraft

When a person moves from a poorly lit area to a well lit area, what is the minimum time they
should allow for the eyes to adapt?.

7 minutes.
7 seconds.

30 seconds.

30 minutes

Structured process used to investigate events caused by maintenance technician and/or

inspector performance:-

Criminal Investigation
MEDA

Fault Discovery Process

Error Detection and Cause Identification (EDCI)

An engineer is performing a task in less than ideal conditions in order to meet an operational
deadline is:-

Committed a routine error

Committed a situational violation

Making a rule based slip

Making a rule based behaviour

Application for Certificate of Registration (C of R) is made on:-

CA Form 29
CA Form 25

CA Form 20

CA Form 28

70 - 80% of the total focusing ability of the eye is carried out bythe.

iris.
retina

lens.

cornea

The average capacity of the working memory is about.

7 chunks of information.
4 chunks of information.

12 chunks of information.

chunks of information
At what distance should a person without hearing difficulties be able to hear an average
conversational voice in a quiet room.

2 metres (6 fee
3 metres (9 feet.)

1 metre (3 fee

4 metres ( 12 fee

The continuing capability of the aircraft to perform in a satisfactory manner the flight operation
for which it was designed is termed as:

Maintenance
Condition monitoring

Airworthiness

On-condition

Component marking in accordance with CAR 21 subpart –

P
Q

The normal human body temperature is:-

350C
370C

300C

420C
A regular behaviour of an individual is known as.

the norm.
habit.

culture.

Social Psychology

Operator shall mention in his __ manual as to when and where MEL item will be attended to

Aircraft maintenance manual

Quality control manual

Maintenance system manual

"Quality assurance manual"

Who is responsible for establishing and promoting the safety and Quality policy in CAR 145
AMO

Accountable manager
Quality control manager

Workshop manager

All are correct

A good practice for a shift handover is for shifts to be specifically rostered so there is an overlap
of.

2 - 3 hours.
5 - 10 minutes.

10-15 minutes

20 - 30 minutes.
The document which described Design organization approval

CAR145
CAR147

CARM

CAR21

A company's safety policy should be defined in.

in CAP 716.
the Maintenance Schedule.

the Maintenance Organization Exposition.

in CAP 715

Weight Schedule shall be approved by:-

DGCA
Quality Control Manager

RAO

Accountable Manager

MMEL is approved by:

Manufacturer
RAWO

DGCA

None
Specific environmental condition are identified in

Maintenance data
Standard work procedure

Inspection card

All

How long can the aural reflex protect the ear from loud noise?.

5 seconds.
15 minutes.

15 seconds.

5 minutes.

"The document which described Design organization approval"

CAR 21
CAR 145

CAR 147

CAR 66

For preparation of load & trim sheet:-

A children having 11 years age his weight is counted as 35 Kg

A children having 11 years age his weight is counted as 30 Kg

A children having 11 years age his weight is counted as 25 Kg

A children having 11 years age his weight is counted as 15 Kg

If a person is colour blind, which colours would be most difficult to see?.

Red and green.

Blue and red.

Yellow and red.

White and red.

Test-flight shall be carried out, if practicable, at

Minimum AUW
AUW

As desired

Both

Experience requirements for category B2, B1.1 & B1.3 licence is:-

5 Years
6 Years

3 Years

2 Years

What part of the eye is colour sensitive?.

The rods.
The cones.

The iris.

The lens.
Operator technical log is preserved for

24 months
12 months

36 months

48 months

Operator technical log approved by

a)RAO
DGCA

QM

all of the above

Defect may be defined as

Condition which preclude the item from its intended function

Condition arising due to any cause which would preclude it from its intended function

Condition arising due to any cause other than damage which would result in precluding it from

None of the above

Organised and co-ordinated pattern of psychomotor, social, linguistic and intellectual activity is:-

Skill
Art

Attitude

Knowledge
Extreme discomfort experienced by a maintenance engineer due to working in a confined space
is Known as.

claustrophobia.
acrophobia.

agoraphobia

Hypoxia.

What happens when you break the 'chain of error'?.

Accident happens.
Pilot submits report within 72 hours.

does not happen.

AME submits report with 24 hours

Which one does not define the human performance and limitations?

Noise
Memory

Incident

Attention and perception

Murphy's law is perpetuated mainly by.

violations.
poor aircraft design.

complacency.

Poor regulations
What is a latent failure?.

A mistake that has already been made, but has not yet caused an accident.
bad instruction from a manager who is out of touch with maintenance.

A failure which could not have been predicted.

A mistake that has already been made& has caused an accident.

HD Maintenance organisation use equipment, tools & materials as specified by:-

Operator
DGCA

Manufacturer

AME

Component marking in accordance with CAR 21 subpart –

P
Q

Back

Next

Page 2 of 4

Clear form
Never submit passwords through Google Forms.

This form was created inside of The Bombay Flying Club. Report Abuse
Forms