Strategic Map recon unit is discovered and is engaged in a • When a unit wishes to determine the composition Recon Escape Scenario (see below). of another unit on the strategic map, it will enter o Recon Unit roll = Targeted unit roll – reroll. the same space and a Reconnaissance Check will be • Each element of a unit has a detection factor (DF) made. Note: once a unit has declared that they are which is equal to that element’s walking / cruising undergoing the Reconnaissance Check, they cannot MP. be attacked during that strategic turn. • The lowest DF in the recon unit will be subtracted • The Recon Unit rolls 2d6 vs the Targeted Unit 2d6 by the highest DF in the group targeted for recon. as an Opposed Action Check. The difference will be applied to the recon unit’s • Roll results: Reconnaissance Check roll. o Recon Unit roll > Targeted Unit roll – the • The experienced gained by each pilot of a recon unit recon unit identifies all units in the target will be 0.25 xp per of the element targeted group group and remains undetected. identified.
Modifiers to Detection Factor
Mech equipped with Jump Jets +1 Pilot Experience Level Recon Unit Size 4 - # of elements Ultra-Green -2 Equipped with ECM +2 Green -1 Equipped with BAP +2 Regular 0 Veteran +1 Elite +2
2. All elements of the Recon Unit must
Game Map be either 34 inches away from; out • The result of a failed Reconnaissance Check by the of Line of Sight of; or in a location recon unit will result in a Recon Escape Scenario. where they can be hidden from all • Recon Escape Scenario Setup: elements of the Targeted Unit. o A random element from the Recon Unit will 3. If it is not possible to meet the be placed in the center of the game map. above conditions, the location for This is the Discovered Element of the unit. the elements in question can be o A random element from the Targeted Unit placed at the discretion of the GM. will be placed 2 inches from the Discovered o Once all starting locations are determined, Element. a random edge of the map will be selected. o The remaining elements of the Targeted It will be the objective of the Recon Unit to Unit will be placed in locations around the escape from the map off of this edge. map that are no closer than 34 inches to the • At the end of a Recon Escape Scenario, the elements Discovered Element. of the Targeted Unit that were seen (in Line of Sight o The remaining elements of the Recon Unit and within 34 inches of an element of the Recon will be placed on the map in locations that Unit) will be successfully identified. obey the following conditions: • Experience will be awarded as per normal scenario 1. All elements of the Recon Unit must rules. be at least 20 inches apart from each other.