Professional Documents
Culture Documents
Databus V3
Databus V3
Databus V3
14. How does MIL-STD-1533 put data onto the data bus?
a) Through the bus controller
b) R1 (remote terminal)
c) SSIFU (sub-system interface unit)
17. How many LRUs can be connected to an ARINC 629 data bus
a) 120
b) 20
c) 60
22. An ARINC 429 Binary Coded Decimal word occupies word bits
a) 11 - 28
b) 11 - 29
c) 1 – 8
30. On an ARINC 629 data bus, the maximum amount of current-mode couplers per data bus
is
a) 46
b) 120
c) 64
32. A current-mode coupler contains an E-Core assembly. The purpose of the E-Core is to
a) couple the signal to the data bus
b) provide effective screening of the signal through the current-mode coupler
c) enable easy access for monitoring of the signal
36. Care must be taken when installing ARINC 629 cables into bus panels, damage to cables
can cause
a) arcing of high voltage signals
b) standing waves.
c) corrosion of the conductor
39. What is the Low Speed transmission rate for ARINC 429?
a) 12 – 14.5 kbits / second
b) 100 kbits / second
c) 120 kbits / second
40. Once an ARINC 629 LRU has transmitted a message it will wait how long before
transmitting again?
a) Until the end of the synchronization gap.
b) Until the end of the transmit interval
c) Until the start of the terminal gap
42. A arinc data word is bits 11-29, if bits 11-18 are patched which of the following would be
the LSB bit
a) 19
b) 29
c) 21
51. The ARINC 429 system uses the following system to transfer data
a) non return to zero
b) harvard bi phase
c) bi-polar return to zero
56. Data to flight data recorder can be taken form a communal data bus if
a) it goes directly to it
b) the power is within flight data recorder limits
c) if source isolation has been considered
57. In arinc 429 data field is bits 11 to 28. If the bits 11 to 18 had pad bits, the L.S.B. Of the
data would be
a) bit 19
b) bit 11
c) bit 28
58. The BCD data field of arinc 429 is contained within bits
a) 1- 8
b) 11- 29
c) 11- 28
62. Why does an ARINC databus system send data to LRUs in series?
a) More information can be sent
b) Takes less time
c) Saves weight
63. Can an LRU transmit and receive on more than one 629 bus?
a) Yes
b) No
c) Only if paralleled
65. A BCD word occupies bits 11-29, if 11-15 are filled with padders then the LSB of the word
will be
a) 16
b) 29
c) 11
66. In an Arinc 429 Word label-representing heading is 320, this is represented in bits 1-8 as
a) 01101000
b) 01011001
c) 00001011
70. The data format use to transmit signal to flight data recorder
a) Manchester 2 bi-phase 12 bit
b) Harvard bi-phase 12 bit
c) Bi-Polar RZ 12 bit
76. A current mode coupler contains E core assembly. The purpose of the E core is
a) couple the signal to the data bus
b) provide effective screening of the signal through the current mode coupler
c) enable easy access for monitoring purposes
78. A heading reference of 320 degrees in a word label format would be written as
a) 101010001
b) 11010000
c) 01000111
1 B 11 C 21 C 31 A 41 C 51 C
2 B 12 A 22 B 32 A 42 A 52 B
3 A 13 B 23 B 33 A 43 B 53 B
4 A 14 A 24 C 34 C 44 A 54 C
5 C 15 A 25 B 35 A 45 B 55 A
6 B 16 B 26 B 36 C 46 B 56 C
7 C 17 A 27 B 37 C 47 C 57 A
8 A 18 B 28 A 38 A 48 C 58 B
9 B 19 B 29 A 39 A 49 C 59 A
10 B 20 B 30 B 40 B 50 B 60 A
61 B 71 C 81 91 101 111
62 C 72 A 82 92 102 112
63 A 73 A 83 93 103 113
64 B 74 B 84 94 104 114
65 A 75 C 85 95 105 115
66 A 76 A 86 96 106 116
67 B 77 B 87 97 107 117
68 A 78 B 88 98 108 118
69 B 79 89 99 109 119
70 B 80 90 100 110 120