Professional Documents
Culture Documents
FLSUN QQ-S Pro Upgrade To MKS Robin Nano v3 and TS35 v2.0
FLSUN QQ-S Pro Upgrade To MKS Robin Nano v3 and TS35 v2.0
TS35 v2.0
• Use the template to mark and then cut the slot at the back of the printer so that the SD card
and USB ports will fit from the new motherboard.
Step 2: Fit the new motherboard
• Fit the Nano mount in to the case and secure with two screws on the right of the picture
below. I used computer case screws.
• Fit the new Nano v3 to the mount with the motherboard screws kept from step 1.
• Connect all the cables to the new motherboard and install the TMC drivers.
Step 3: Fit the display
• Install the display mount into the slot in the case with the original display screws.
• Fit the small hinge to the display mount with 2 M3 10mm screws plus two nuts.
• Feed the display cables through the slot in the display mount.
• I suggest you use the Marlin Colour UI not TFT_LVGL_UI as autolevel does not work in LVGL
along with advanced pause.