Professional Documents
Culture Documents
15-18HYUNDAI TUCSON With Lower Latch
15-18HYUNDAI TUCSON With Lower Latch
15-18HYUNDAI TUCSON With Lower Latch
3. Remove the left and right trim 4. Remove the main trim panel 9. Install our tailgate screw ball (same 10. Install our electric pole ("L"
panels of the tailgate left and right) left "R" right)
5. Pry open the gas spring snap ring, 6. Remove the original car body 11. Remove the rubber plug of the 12. nsert the pole wire into the
and remove the original car pole bracket (same left and right) original car (same left and right) hole (same left and right)
(same left and right)
13. Plug the rubber plug (same left 14. Unplug the original car lock 19. Fix the suction motor 20. Location of GND
and right) wire and dock with our wire
15. Unplug the original car button 16. Remove the original car lock 21. Remove the trim panel in the 22. Get constant electricity in
cable and connect it with ours. Or our hook trim main driving chart the fuse box
white wire is connected to the green
wire in the picture
17. Remove the original car lock hook 18. Install our lower lock 23. Fuse definition diagram 24. Unplug the original car OBD
and connect with our OBD
After then installation is completed, you must set the tailgate learning. Make
sure that the door can be opened and closed in place. (Raise the tailgate to
ideal height. Then press the tailgate button for 3-5 seconds. You will hear a
sound “Deep——” and then loose your hand. Press the tailgate button again
and close it. You will hear a sound again “Deep”. Tail gate learning is finished.
25. Drill holes in the main driving trim 26. Threading diagram (black:
panel and install our front buttons front button line red: power line
green: protocol line)
When the tailgate cannot be opened normally, find the original car
emergency safety lock in the trunk, open the emergency cover and
pull the emergency switch to open.