Professional Documents
Culture Documents
Work Table (ASEL)
Work Table (ASEL)
Work Table (ASEL)
Veracruz I
Students:
Career:
Module:
Teacher:
Proposed:
The purpose of this report is to show the evidence of the maintenance of a worktable,
which with the help of previously acquired experience and knowledge of the practices
1. Bill of materials
2. Gantt diagram
3. Maintenance Testing
5. Conclusions
1.- Material's List
cutting tweezers
Razor
Insulation tape
14-gauge wire
not.
Figure 5 : We verify that the tie is correctly Figure 6 : Finally we connect the last direct
so that it does not short. cables to a plug so that it has current and we
It was decided to do this, because every time we use the worktable we cannot connect
anything since we did not have light on the table and maintenance was given.
So far the approximate cost is $700, since it can easily be left like that and not be fixed,
We noticed that the table did not pass current, and after verifying that it was well
connected, and that there was electrical energy, we proceeded to observe what was
going wrong, we made a change of wiring and we tied the cables again in the outlets.
We observed that the worktable on one side was conducting electricity and on the other
not in its contacts, we began to repair the electrical installation of the table.
We had the idea of repairing the table because on one side it worked but on the other it
We carried out maintenance on a worktable that did not have electricity, so it was not
The table where we would work, on the one hand it conducted electricity and on the
other not in its contacts, we began to repair the electrical installation of the table to have