Professional Documents
Culture Documents
Calibrator 4 20a PDF
Calibrator 4 20a PDF
Calibrator 4 20a PDF
2 x 9 Volt Regulator
In Out Basic Circuit
Adj
The LM0327 voltage regulator holds the
voltage between Adj & Output pins at 1.25
Volts, therefore current is set by the value of
resistor chain
+1 mA
1250 Ohms
+2 mA
625 Ohms
Batt Test
+4 mA
312.5 Ohms
1K 12 V +8 mA
156 Ohms
2 x 9 Volt +12 mA
104 Ohms Note 4
In Out
Adj
312.5 Ohms
4 mA
C
Note 2
Transmitter Simulate
+ - +
-
Source for 4 wire loops
Note 2
250 Ohm
Jumper
Notes
1) Small capacitor across regulator pins to prevent oscilation with some loads
2) The negative terminal is mounted adjacent to Source positive terminal so that
250 Ohm jumper connects easily to give 1-5 VDC.
3) Switching battery on Source mode gives 4 mA, Connecting in Transmitter
simulate mode also gives 4 mA
4) Use high quality fixed resistors with wire wound trim pots for accurate calibration 4-20 mA Loop Calibrator
Roy Matson