Professional Documents
Culture Documents
Moment of A Force I
Moment of A Force I
Instructions: Answer ALL items below and show appropriate working where necessary.
(Assume g = 10 N kg-1)
1. Calculate the moment of force of 40N that is made to act 2.0 m normally from a
pivot.[2]
2. A Force of 12N acts 1.3 m perpendicularly from a fulcrum, evaluate the torque of
the force.[2]
3. Determine the moment of a force of 0.09 N which required to tip a lamp of 300
mm tall, at the edge of its base.[2]
6. The crank of bicycle pedal is 16 cm long and the downwards push of a leg on it is
400 N. Calculate the moment of the effort when:
Bolt
Spanner
E = 80 N
Figure [W]
7. A Mechanic uses a spanner such as the one above in figure [W] to turn a bolt B. If
an effort of 80 N is applied at P 15 cm from the axis(pivot), Calculate the moment
of the effort :-
b) when the mechanics arm is pulling instead at a 45o angle to the horizontal
of the spanner. [2]
Moments I Wrksht
axis
20 cm
Nut
Spanner
F = 50 N
Figure [N]
8. A Girl uses a spanner as in figure [N] of length 20 cm to tighten a nut. If she pulls
at right angle to the end of the spanner with a force of 50 N:-
9. The figure [T] (i) below shows a side view of a uniform trap door 2 m long of
mass 12 kg hinged at A. Two methods of lifting the trap door are illustrated below
in figure [T] (i) and (ii) ;-
F
A B
Hinge
a) In Figure [T] (i) 1st method the trap door is lifted by a vertical force F find
the value this force.[2]
F1
C
A 30o B
Hinge
b) In Figure [T] (ii) the 2nd method a force of F1 is applied in the direction
BC making an angle of 30o with AB. Calculate the length AC and hence
find the value of F1. [2]
F1 = 30 N
Juice Punch
pivot
Juice Tin
2.0 cm 12 cm
Figure [L]
10. A boy uses a punch as in figure [L] above to open a a hole in a tin of fruit juice.
The hook on the punch is below the rim of the tin and acts as a pivot. If the boy
applies an upward force of 30 N and it just opens the tin.[2]
i) What is the maximum resistance force on the top of the tin? [2]
ii) draw on the diagram the direction in which the resistance force will act.[1]
0 15 40 100
m Figure [B]
ii) Calculate the moment about the knife edge in its the shown balanced
condition/state of the force due to the mass of the ruler.[2]
ii) If the weight of the rule is 0.90 N, calculate the position of its centre of gravity.[2]
Moments I Wrksht
T1 = 0.25 N T2 = 1,25 N
x2
A B C
W
Figure [H]
12. Figure [H] above shows a uniform metre rule of weight 1N suspended from two
spring balances. A load is attached to the extreme right-hand end (C). The spring
balance attached to the extreme left-hand end of the rule (A) reads 0.25 N. The
spring balance attached at (B), a distance x from the right hand end reads 1.25 N.