Professional Documents
Culture Documents
Union VS Sewing Machine Instruction Manual
Union VS Sewing Machine Instruction Manual
Union VS Sewing Machine Instruction Manual
L yl
77—h‘
9‘0 o‘o'o’o‘fiwo:‘5’;’.9mm?“’&'¥’
wfi 2T? 4
¥A&r:
n:
{fl
INSTRUCTIONS
A”;'Wflafio32-‘Eéu'ofl‘a'a‘a‘»’p’.9&’do€o?u‘mat
UNION
f
-'m°v
Sewmor Machine
aaéfiaéégaséP, 6}; .S A 3 3 53.2 3 F it 2 3:3 3. £533 £35"
£556? “Va-7333
F.1-
s—‘f~w
1 WI
ATTACHMENTS I
/
aflzéééaaaaaaaaaaaunaaz~
TOLEDO. uum
DJ
0
Plusnxu
EW
3»
13850.
gfl¢& éflfiig
a)?oWb'Sfi’fiQSSS’oPMMw‘c’sfl‘MM. ”wasmrwa
38’
51:3}?
I,
I" INSTRUCTIONS
I
Fl USING
AND
I.
$41! '
I, ’I: u.‘
ATTACH M E NTS.
TOLEDO, OHIO, U. S. A.
lNDEX TO READING
V
0
pl
>
Placing Machine on the Table.
fiflcafliflbfifiw
General Directions, . .
Oiling Machine, . . .
Setting the Needle, . .
Winding the Bobbin, . .
Threading the Shuttle, .
Threading the Machine. .
Regulating the Tensions, .
Regulating the Feed, . .
Size of Needle and Thread,
D1 anemone FOR USING ATTACHMENTS.
-
Narrow Hemming, . .
a;
Binding. . . . .
Felling, . . . . .
Quilting, . . . .
Braiding, . . . .12
Tue-king, . ,- .
Cal-ding, . . .
Rufiling; . . .
List of Attachments, . .
INDEX TO ILLUSTRATIONS.
Transparency—Cut No. 1. .
Threading Shuttle—Ont No. 0
Narrow Hemming—Uut N0. 4, .
Felling—Cut. No. 6, . . .
Quilting—Cut No. B, . .
Braiding—Cut No. 7, . .
T Licking—Cut No. 8, . . .
Cording—C-ut No. 9, . .
Rufiing—Cut No. 10, .
But No. LTTransparent Vlew.
Place shuttle in IeIt hand, point toward you ; insert bobbin; then
thread through the hole in end of shuttle, press the finger slightly
against the end of bobbin, than dmw threml under guard of spring. and
then straight with shuttle. (Sui Cut No. 2.) Drop the shuttle into car-
rier point end first, and it is ready for use.
FACE PLATE-
F EED SHAFT
REVERSIBLE FEED.
We justly claim for this machine a great improvement in sewing
either way. backward or forward, without. the addition of a single part
to the mechanism. This improvement is considered by experts to be
the finest that has been added to sewing machines for the last twenty
years. The reverse feed is obtained by moving the stitch regulator to
the left toward the needle as far as it will go. and by moving the
stitch regulator buck to the right, to the second line on the indicator, it
will make the same length of stitch forward. This reverse stitch is
used for double stitching any part of a seam. fastening ends of seams
without turning the work, and embroidery where you do not stop to
turn the goods. filling perfectly any flower, pattern or design that the
operator may desire. 1
“1
become necessary, however, to raise or lower the feed, it can be done
by taking the screw-driver, loosening screw in the side of feed bar
on
under side of machine, and pushing the feed dug up or down, as may
be required. '
line of Si 0 are it
Noodln. CLASS OF GDODS. lnot! stilt."
6 Heavy Culicoes. Light Woolen Goods, l lcm'y Sllks, etc. ‘Z'K’fl? gag-{film
40 to 80 Linen.
Use none but the best thread, and always an unglnzed or soft finish
in preference to a glazed threml. You need not expect to make it
smooth, even stitch with poor llll‘L‘lHl. If as strong a seem as is possible
8 UNXON SEWING MAUUINE INS’I'RUC’I‘IUNS.
is desired, use the same size thread on both sides. If ynu desire the upper
[Ida the nicer, use heavier thread on the bobbin, and Vlcu verse.
Narrow Hemnning'.
«7O'
UNION 51:WING MACHINE lusrnucnons.
Take the premier {out nll‘ uml fasten the hummer to the presser bar
in place nil“ the loot; see that the needle passes through the center of
the hole in the hammer, and fasten it securely to the presser bar by the
Screw ; raise the presSer bur, pass the edge of the cloth into the hammer
in the manner she in the out, passing it forward into the hemmer
as far as the malleable, in order that the food may at once catch the
cloth. By clipping off the corner of the cloth before inserting it into
the hammer you can start it without difficulty; then let the hemmer
down upo the feed and operate the machine as usual. Hold the goods
with the ' t hand as shown ' the illustration: should the edge of the
goods beginno run out of the 115m”. move it to the meet; should too
much run into the hammer, move the goods to the LEFT. A’hbout throe-
eighths of an inch _in width is about as much of the goods as is usually
required to form ‘s. perfect hem. If the stitch takes the hem too hu'Irom
the edge, turn thechetuuier a little to the right. If, on the contrary, the
stitch does not catch the edge of the hem, turn the hemmer a little to
the left.
BINDING.
Attach the binder to the bed of the machine with the thumb screw
When you wish to put on s hem binding, cut your binding material
about three-fourths of an inch wide; place the binding in the scrolls, and
the material to be bound between the scrolls; let down the presser foot
and hold your work, keeping the goods to be bound between the scrolls
and well back against the binding. The binding should be out bias.
Ordinary binding about three-eighths of an inch wide can also be put
on with this hinder.
M
1111
1111
1111
1 111111111111 1 y ‘
[1111111111111
1 1111111111
1 11111111111111111
Cut No. 5.
FELLING.
[See Cut No. 5.]
Sew the two edges of the material together, the under one project—
ingnn eighth of an inch beyond the upper, using the hammer as a
pressor foot; leave the ends of the thread about two inches long at.-
’tachud to the material ; open the work out and crease the seam down to
the left, the wide part on top; take hold of the two threads and draw
the edge to be felled into the hammer as far us the needle, and let down
the hemmer upon the work and start the machine; pull on the thread
until two or three stitches have heen taken ; keep the cloth smooth and
guide it into the hemmer as shown in Cut No. 4 for narrow hem.
UNION Snwxo MAcumE Issmuwxoas. n
Cut No. 8.
QI‘]LTING.
Insert the quilter gauge through the mmlll hole in the presser bar,
and insten with the small screw in hack of pi'essnr bar, moving it to the
right or left, to get the required width of the rowa of stitching. Raise
or inwer the gauge, according to the thickness of the goods. Having
mndn the first row the desired distance from the edge, place the Work
so
that this row will he under and in a line with the lower edge of the
quiltcr gnnee. whieh will thus form 3 guide. for each row of stitching;
the last. row made ulwnys passing under and in ii line with the gangs
while stitching the next.
1? UNION 5»;me MACHINE INFTIH‘l'l'luNS.
Cut "0. 7s
BRAIDING.
Substitute the hruider [or thr- presser foot. Pass the hrnid down
through the first hole in the bruiiler. drmring it hack sqnurely under the
needle, and stitch it on the goods as in ordinary stilt-hing. Have the
pattern stamped on the right side of the goods, and turn the work rs
may be necessary to follow the pattern. If the needle does not pass
down through the center of the braid, swing the braider to the rightor
left as may be refluired.
Urdu); b'uwlxu .\l u NINE lssmuurmxs.
L ,
pwllllwlfl
w
Cut No. 8.
FOR USING THE ’l‘llCK NIARKER.
[See Cut No. 8.)
Place the tucker on the umchinu, pass the small hook on the long
arm of tucker around the. needle; set. the gaugn the right distance from
the needle [or the width of luck desired; fnstmx to the bed plate with
thumb screw; now move the marker until the smne number is at the
gauge line as on the gauge, and tightvn the little thumb nut securely;
if more spaceia desired. loosen small nut and move marker forward;
fold the cloth for the first tuck, pass it under the marker, and up to
gauge ; let. down the foot and sew. keeping the orlge carefully up to the
gauge; fold the next tuck by the crease made by the marker, and pro-
ceed as befnre, placing the Luck just made so it will run under the little
spur seen near the creasing blade.
14 UNION SEWING Mummy: iNSTRL‘C'I‘lONS.
LT."
‘
‘v’ “132
(in! No. 9.
CORDING-
[SM Cut No. 9.]
Attach the cordcr in place of the presser foot, with Mr bow to the
ltfl, so that the needle passes through the center of the needle hole in
the cord foot. The cord, which should be of uniform size (a. good cord
for most work is No. 4 crochet cotton), is passed through the bow into
we'loxig slut in the lower arm.
UNION SEWING MACHINE lms'muc' 10118."
\
.1\\\ xx ,
Also 1 Combined Hemmer and Feller, Thumb Screw, Oil Can filled
with Oil, Quilter, 2 Screw-Drivers, Gauge, Wrench, Six Assorted Nee-
dlea, G Bobbins, Book of Instructions.
'. ).-".‘. '. t 21-1
' 1