PRIME REVIEW ONLINE
‘MECHANICAL ENGINEERING REVIEW
SPLINES, RIVETS & WELDED JOINTS
SPLINE!
‘| ‘Splines are permanent keys made
= Integral with the shaft and fiting nto
keyways broached into mating hub.
‘They are used to permit relative axial
‘motion brween the shaft and hub,
usually consists of four, six, eight or
1, The torsional capacity of a spline fitting is based on
the maximum allowable pressure on the active surface
oon the splines. The major diameter D of the splined
fitting is 7Smm, the minor diameter d is 60 mim, and
the coefficient of friction f is 0.10. The number of
splines is 6. Considering the pressure in the active
surface to be be 7 Mpa, determine the length of spline
needed for a transmitted torque of 750 Nem.
A. 74.50. mm C. 84,50 mm,
B. 50.74 mm D. 70,54 mm
MACHINE DESIGN & SHOP PRACTICE
‘SOIVED & DISCUSSED PROBIEMS ONLINE
2. Consider a 304.8 mm section of a single-riveted lap
joimt made up with plates of 6.35 m thickness and 6
rivet holes, 17.45 mm in diameter. Each plate and the
six rivets carry the entire load. Design stress for
bearing, 1406 ke/sq.cm and for tension, 703 kg/sq cm.
Assume that the rivets will not tear or shear through
the plate to the edge of the joints. Determine the safe
tensile load.
A. 8,932.6 kg
B. 9,832.8 kg
C. 3,628.3 ke
D. 2,896.3 ke
3. Consider a 304.8 mm section of a single-riveted lap
joint made up with plates of 6.35 m thickness and 6
rivet holes, 17.45 mm in diameter. Each plate and the
six rivets carry the entire load. Design stress for
bearing, 1406 ke/sq.cm and for tension, 703 ka/sq cm.
Assume that the rivets will not tear or shear through
the plate to the edge of the joints, Determine the
efficiency of the joints
A. 65.65% C.95%
B. 50.55 % D.43.%
WELDED JOINTS
Corner Joint Edge Joint
BUTT WELD FILET WELD
wae
STRENGT OF LET WELD
vypatense
ns
oe
Single Fillet Weld Double Fillet Weld
4, A double fillet welded joint with parallel fillet weld of
length 5 cm and leg of 12 cm is subjected to a tensile
force of 320 kg, Assume uniform stress distribution,
solve for the shear stress in the weld.
A. 53.7 psi
B.3.77kPa
Please log-on to www primereviewcenter,com for the
enhancement of Elements(Terms) in Mathematics &
Basic Engineering Sciences, Power & Industrial Plant
Engineering and Machine Design,
C. 45.67 kglem?®
D.5.23 ksi