Professional Documents
Culture Documents
Grasshop
Grasshop
Grasshop
Lozano
Section: BTLE IA-2A
TITLE
GRASSHOPPER RIDE
I. Objectives
To Create a grasshopper-based wheel toy.
To be able to make toy.
II. Description
• A toy car shaped like a grasshopper, with two larger wheels at the back and a single wheel
underneath the toy to provide balance, also known as the hidden wheel.
Item
Description UOM Unit Cost Qty Total Cost Supplier
no.
Good lumber
1 feet 200 1 36 php Maddog hardware
(2x3)
V. Procedure
Steps:
1. Using a measuring tape, take all of the measurements specified in the draft project.
2. After measuring, prepare all of the measured woods for cutting with a handsaw.
3. The chisel is used to carve the 2x3 into the head or front vehicle shape of the grasshopper.
4. The hand drill used on the 2x3 wood makes holes 2 inches before the front and end of the
wood.
5. Draw three 2x3 circles for the tires and cut them out with a handsaw.
6. After cutting three tires, use sandpaper to remove extra and complete the tire circle.
7. Drill holes through the center of the wooden tires.
8. And carve a 1x2 as a connector for two tires in the back.
9. Use the stikwel to join the stick and the tires and let it dry for a minute.
10. While drying, choose the cut 1x2 13(2) cm and 18(2) cm and carve it for grasshopper legs.
11. Drill holes along the borders of the 1x2 to link the joints of the grasshopper's legs with a
stick so it may move freely while the tires rotate.
12. After drilling the holes, insert the legs, apply stikwel, and allow to dry. When the tires begin
to spin, the legs will generate a movement.
13. Sandpaper is used to remove all of the excess wood while also making it smooth and clean.
14. After sanding, apply the paint in a single stroke, set it aside, and let it dry. Then you simply
create a grasshopper ride.
Name: Arthur T. Lozano
Section: BTLE IA-2A
VI. Sketch/Drawing
Name: Arthur T. Lozano
Section: BTLE IA-2A