Shutdown of ports: Go to port interface. Tell which IP it is receiving from port. >shutdown > (interface) Or if range, >ip address (ipaddress) (subnet) (config)#interface range fa06-24 > no shut >shutdown Enable password: SMTP: (config)#enable password undertale Set IP through config window. VTY: Services>Email Service> ON SMTP and POP3 > (config)#line vty 0 15 “example.com” domain name > set (config)#password undertale To add users: (config)#login User: user 1 (config)#exit Password: 123, > “+ button”. (config)#line vty 0 15 CONFIGURE EMAIL on relevant PCS: VTP: Incoming/Outgoing Mail Server: Server IP. (config)# vtp mode server Email address: <username>@<domain (config)#vtp domain ccna name>.com Setting VLAN names: (in config mode) FTP: Assign IP, subnet mask, gateway, DNS server. >vlan 10 Use Setup > (user 1), check on read, rename, list >name Faculty and add. >vlan 20 (do the same for second user) >name Students PC1: Command prompt > “dir” > ping ftp server > #show vlan “ftp <ftp ip> > Enter Username and password > Trunking between switches (do it between both “dir” > get asa842-k8.bin > quit > “dir” two switches for vlans u want to trunk): >(interface where switch sae connected) HTTP: >no shutdown Assign ip,subnet,gateway,dns >switchport mode trunk Service > http > “ON” > index.html edit > “welcome >switchport trunk allowed vlan 10,20,30 to hello”> open web browser in pc and verify
Access mode config, to tell which port will DNS:
have which VLANs: Assign ip,subnet,gateway,dns (being itself) (config mode) Service: click on dns service from left side, on the >(interface with which interface u want to access) service, write www.dcn.com , address ip address it >switchmode mode access should redirect to. Confirm by access that website >switchport access vlan 10 from the pc. > exit Dynamically assing IPs using router: (config) >ip dhcp pool cisco Router On Stick: >network <network not ip address> <subnet> Router(config)#int Gi 0/0/0 >default-router <Router-gateway ip address> Router(config-if)#no shutdown > dns-server <dns-server ip> Router(config-if)#exit >ip dhcp excluded-address (range of ips u don’t Router(config)#int Gi 0/0/0.10 want to assign, like, “192.168.1.1 192.168.1.7) Router(config-if)#encapsulation dot1q 10 Router(config-if)#ip add 192.168.10.1 255.255.255.0 Router(config)#int Gi 0/0/0.20 Router(config-if)#encapsulation dot1q 20 Router(config-if)#ip add 192.168.20.1 255.255.255.0 Vlan doesn’t depend on IP(until inter vlan routing)