Download as pdf or txt
Download as pdf or txt
You are on page 1of 7

VICINITY MAP: SERVICE ENTRANCE:

GENERAL NOTES:
1. All telephony wiring shall comply with relevant telecommunications industry standards and
local building codes.
2. Reference to specific standards (e.g., TIA/EIA-568) can be added here if applicable.
3. Use appropriate cable type for voice applications, such as Category 5e or Category 6 for voice
LEGENDS:
and data convergence.
4. Label all cables at both ends with a unique identifier (e.g., room number, outlet number).
5. Terminate all cables with RJ45 jacks following the designated standard (e.g., TIA/EIA-568B).
6. Maintain proper grounding throughout the entire telephony system to minimize noise and
ensure safety.
7. Use approved conduit or raceway to protect telephony cables from physical damage and
environmental hazards.
8. Maintain appropriate clearance between telephony cables and power lines to avoid
interference.
9. All installed telephony cabling shall be tested for continuity, polarity, and signal strength.
10. Provide clear and concise documentation of the telephony wiring system, including cable
routes, outlet locations, and jack terminations.

DESIGNER: PROJECT TITLE: SHEET CONTENT: SHEET NO.:

MANALASTAS, JOMEL V. PROPOSED TELEPHONE WIRING FOR A FIVE-STOREY SCHOOL BUILDING SERVICE ENTRANCE
AND VICINITY MAP ECE.1
BSECE 4A
LOCATION: CORNER AYALA BLVD, SAN MARCELINO ST., ERMITA MANILA

MAP
DESIGNER: PROJECT TITLE: SHEET CONTENT: SHEET NO.:
PROPOSED TELEPHONE WIRING FOR A FIVE-STOREY SCHOOL BUILDING
MANALASTAS, JOMEL V.
GROUND FLOOR ECE.2
BSECE 4A
LOCATION: CORNER AYALA BLVD, SAN MARCELINO ST., ERMITA MANILA
DESIGNER: PROJECT TITLE: SHEET CONTENT: SHEET NO.:
PROPOSED TELEPHONE WIRING FOR A FIVE-STOREY SCHOOL BUILDING
MANALASTAS, JOMEL V.
2ND FLOOR ECE.3
BSECE 4A
LOCATION: CORNER AYALA BLVD, SAN MARCELINO ST., ERMITA MANILA
DESIGNER: PROJECT TITLE: SHEET CONTENT: SHEET NO.:
PROPOSED TELEPHONE WIRING FOR A FIVE-STOREY SCHOOL BUILDING
MANALASTAS, JOMEL V.
3RD FLOOR ECE.4
BSECE 4A
LOCATION: CORNER AYALA BLVD, SAN MARCELINO ST., ERMITA MANILA
DESIGNER: PROJECT TITLE: SHEET CONTENT: SHEET NO.:
PROPOSED TELEPHONE WIRING FOR A FIVE-STOREY SCHOOL BUILDING
MANALASTAS, JOMEL V.
4TH FLOOR ECE.5
BSECE 4A
LOCATION: CORNER AYALA BLVD, SAN MARCELINO ST., ERMITA MANILA
DESIGNER: PROJECT TITLE: SHEET CONTENT: SHEET NO.:
PROPOSED TELEPHONE WIRING FOR A FIVE-STOREY SCHOOL BUILDING
MANALASTAS, JOMEL V.
5TH FLOOR ECE.6
BSECE 4A
LOCATION: CORNER AYALA BLVD, SAN MARCELINO ST., ERMITA MANILA
TELEPHONE WIRING PROPOSAL

Mr. Manalastas, a 4th year ECE student,


created a telephone layout and cable run for the
five-story building. The total number of telephones
is 36. The first and third floors consist of seven
telephones each. The second floor consists of six
telephones. The fourth and fifth floors are
identical; they consist of eight telephones each.
The selected service entrance is aerial because
the location of the building is near a telco post.The
building has a telecommunications room, an
electronics room, an equipment room, a computer
area, a lobby, a reception area, a bathroom, a fire
exit, and an entrance. I decided to place two
telephones in the reception area so the person in
charge can easily communicate with another
caller. I also place two telephones in the
telecommunications room because the room is

DESCRIPTION divided into two rooms. In the computer room, I


think it is good to place two telephones in case of
The “TUP Student Center” was a proposed project of the University Student Government 2021 crafted by CAFA Dean, Dr. Balais. emergencies. In another room, like the electronics
The floor plan is located at the front of TUP Library and the back of CAFA inside the Technological University of the Philippines in Ermita, room and lobby, I also place telephones.
Manila. It is a five-story school building that will be beneficial to all TUP students.

DESIGNER: PROJECT TITLE: SHEET CONTENT: SHEET NO.:


PROPOSED TELEPHONE WIRING FOR A FIVE-STOREY SCHOOL BUILDING
MANALASTAS, JOMEL V.
PROJECT DESCRIPTION ECE.7
BSECE 4A
LOCATION: CORNER AYALA BLVD, SAN MARCELINO ST., ERMITA MANILA

You might also like