Professional Documents
Culture Documents
CMP Sensor-01-01
CMP Sensor-01-01
[KA24DE]
Wiring Diagram UBS00D6E
EC
BBWA1060E
EC-271
DTC P0340 CMP SENSOR
[KA24DE]
Specification data are reference values and are measured between each terminal and ground.
CAUTION:
Do not use ECM ground terminals when measuring input/output voltage. Doing so may result in dam-
age to the ECM's transistor. Use a ground other than ECM terminals, such as the ground.
TER-
WIRE
MINAL ITEM CONDITION DATA (DC Voltage)
COLOR
NO.
[Engine is running]
[Ignition switch: OFF]
0 - 1V
● For a few seconds after turning ignition switch
ECM relay OFF
4 LG/R
(Self shutoff)
[Ignition switch: OFF]
BATTERY VOLTAGE
● More than a few seconds after turning ignition (11 - 14V)
switch OFF
0.2 - 0.5V
[Engine is running]
● Warm-up condition
● Idle speed
NOTE:
The pulse cycle changes depending on rpm at
idle.
44 PU Camshaft position sen- SEF114V
[Engine is running]
● Engine speed is 2,000 rpm
SEF200T
Approximately 2.6V
[Engine is running]
● Warm-up condition
● Idle speed
NOTE:
The pulse cycle changes depending on rpm at
idle.
Camshaft position sen- SEF195T
49 LG
sor (Position signal)
Approximately 2.5 - 2.6V
[Engine is running]
● Engine speed is 2,000 rpm
SEF196T
: Average voltage for pulse signal (Actual pulse signal can be confirmed by oscilloscope.)
EC-272
DTC P0340 CMP SENSOR
[KA24DE]
Diagnostic Procedure UBS00D6F
BBIA0431E
SEF128S
L
3. Check voltage between terminal 5 and ground with CONSULT-II
or tester.
Voltage : Battery voltage M
OK or NG
OK >> GO TO 5.
NG >> GO TO 4.
SEF040S
>> Repair open circuit or short to ground or short to power in harness or connectors.
EC-273