Professional Documents
Culture Documents
Hand Dryer Installation
Hand Dryer Installation
Hand Dryer Installation
UNPACKING
The hand dryers have been tested before leaving the factory. If any part should be
damaged in transit, please return that part to us for immediate replacement. Each hand
dryer carton contains the following:
a) Hand Dryer
b) Installation Leaflet
c) 4 off No. 10 x 2” Wood Screws
d) 4 off No. 10 Wall Plugs
e) 1 off hexagonal key
SITING
The hand dryers should be sited in such a position that the outlet is approximately the
following heights above the floor, according to use:
Men’s use 48” (1219mm) Ladies use 46” (1168mm) Children’s use 41” (1042mm)
FIXING
Due to the power of the turbo machine, excessive noise may be heard when fixing to a
stud or similar wall. Remove the front cover by unscrewing the two fixing screws.
Position the back plate on the wall and mark through the four fixing points. Drill the wall
to suit the No. 10 wall plugs enclosed. If the supply is to be concealed, drill a hole
through the wall lining up with the 20mm hole in the back plate. Fix the back plate to the
wall with the screws provided.
WIRING OF BACKPLATE
1
Ensure the copper core is clamped by the terminal block screw and not the wire
insulation.
Ensure the main supply is isolated. Hook the dryers onto the back plate hinges. Connect
the wire from the hand dryers to the terminal block on the back plate. REPLACE THE
TERMINAL BLOCK COVER.
When removing your hands from beneath the dryer, the motor will still run for between
3 and 5 seconds. This is quite normal.
TROUBLESHOOTING
Your hand dryer has been fully tested before leaving the factory but should a problem
occur, please check the following:
Automatic Machines
1. That the fuse is still in the fused spur and not blown.
2. That a 13 amp fuse has been fitted
3. That power is getting to the hand dryer
4. The hand dryer has not suffered transit damage
That the 2 slots on the under side of the machine, behind the nozzle, are clear and
have not filled with dirt etc.
The sensitivity on your hand dryer has been set at the factory but adjustment can
be made by following the instructions below:
Touch Machines
2
1) That the fuse is still in the fused spur and not blown
2) That a 13 amp fuse has been fitted
3) That power is getting to the hand dryer
4) The hand dryer has not suffered transit damage.
There are no internal adjustments that can be made to the touch models.
GUARANTEE
Your hand dryer is guaranteed for two years from date of purchase. Should any part fail
during normal use, within this period, just return the faulty part, properly packaged, for
immediate repair or replacement.