Professional Documents
Culture Documents
Cvv65asx M
Cvv65asx M
Cvv65asx M
OBSOLETE
This product was discontinued on: March 27, 2020
Replaced By:
RVV-65A-R3 6-port sector antenna, 2x 694–960 and 4x 1695–2690 MHz, 65° HPBW, 3x RET
General Specifications
Antenna Type Sector
Band Multiband
Grounding Type RF connector inner conductor and body grounded to reflector and
mounting bracket
Performance Note Outdoor usage | Wind loading figures are validated by wind tunnel
measurements described in white paper WP-112534-EN
Page 1 of 5
©2021 CommScope, Inc. All rights reserved. All trademarks identified by ® or ™ are registered trademarks,
respectively, of CommScope. All specifications are subject to change without notice. See www.commscope.com for the
most current information. Revised: September 14, 2021
CVV65ASX-M | CVV65ASX-3X2
Dimensions
Width 301 mm | 11.85 in
Array Layout
Port Configuration
Page 2 of 5
©2021 CommScope, Inc. All rights reserved. All trademarks identified by ® or ™ are registered trademarks,
respectively, of CommScope. All specifications are subject to change without notice. See www.commscope.com for the
most current information. Revised: September 14, 2021
CVV65ASX-M | CVV65ASX-3X2
Electrical Specifications
Impedance 50 ohm
Polarization ±45°
Electrical Specifications
Frequency Band, MHz 790–896 870–960 1710–1880 1850–1990 1920–2180 2300–2500 2500–2690
Gain, dBi 14.4 14.5 17.2 17.4 18 18.2 18.4
Beamwidth, Horizontal, 70 69 60 62 63 63 56.6
degrees
Beamwidth, Vertical, degrees 15.5 14.5 7.2 6.7 6.3 5.5 5.2
Beam Tilt, degrees 0–15 0–15 2–12 2–12 2–12 2–12 2–12
USLS (First Lobe), dB 16 15 13 14 15 15 14
Front-to-Back Ratio at 180°, 28 29 28 30 30 30 29
dB
Isolation, Cross Polarization, 28 28 28 28 28 28 28
dB
Isolation, Inter-band, dB 30 30 30 30 30 30 30
VSWR | Return loss, dB 1.5 | 14.0 1.5 | 14.0 1.5 | 14.0 1.5 | 14.0 1.5 | 14.0 1.5 | 14.0 1.5 | 14.0
PIM, 3rd Order, 2 x 20 W, dBc -150 -150 -150 -150 -150 -150 -150
©2021 CommScope, Inc. All rights reserved. All trademarks identified by ® or ™ are registered trademarks,
respectively, of CommScope. All specifications are subject to change without notice. See www.commscope.com for the
most current information. Revised: September 14, 2021
CVV65ASX-M | CVV65ASX-3X2
Input Power per Port, 350 350 350 350 350 300 300
maximum, watts
Mechanical Specifications
Wind Loading @ Velocity, frontal 205.0 N @ 150 km/h (46.1 lbf @ 150 km/h)
Wind Loading @ Velocity, lateral 169.0 N @ 150 km/h (38.0 lbf @ 150 km/h)
Wind Loading @ Velocity, maximum 396.0 N @ 150 km/h (89.0 lbf @ 150 km/h)
Wind Loading @ Velocity, rear 208.0 N @ 150 km/h (46.8 lbf @ 150 km/h)
Regulatory Compliance/Certifications
Agency Classification
CE Compliant with the relevant CE product directives
Page 4 of 5
©2021 CommScope, Inc. All rights reserved. All trademarks identified by ® or ™ are registered trademarks,
respectively, of CommScope. All specifications are subject to change without notice. See www.commscope.com for the
most current information. Revised: September 14, 2021
CVV65ASX-M | CVV65ASX-3X2
CHINA-ROHS Below maximum concentration value
ISO 9001:2015 Designed, manufactured and/or distributed under this quality management system
REACH-SVHC Compliant as per SVHC revision on www.commscope.com/ProductCompliance
ROHS Compliant
Included Products
BSAMNT-OFFSET – Forward Offset Pipe Mounting Kit for 4.5 in (114.3 mm) OD round
members
* Footnotes
Performance Note Severe environmental conditions may degrade optimum performance
Page 5 of 5
©2021 CommScope, Inc. All rights reserved. All trademarks identified by ® or ™ are registered trademarks,
respectively, of CommScope. All specifications are subject to change without notice. See www.commscope.com for the
most current information. Revised: September 14, 2021