Professional Documents
Culture Documents
Subject: Installation, Testing and Maintenance 6th Sem. / Mechanical/Mechatronics/GE/CAD/CAM Section-D
Subject: Installation, Testing and Maintenance 6th Sem. / Mechanical/Mechatronics/GE/CAD/CAM Section-D
Subject: Installation, Testing and Maintenance 6th Sem. / Mechanical/Mechatronics/GE/CAD/CAM Section-D
of Printed Pages : 4
Roll No. .................. 127265/31765
maintenance.
Q.35 What is the need of Plant layout? Describe two Q.4 Full form of MTBF is ________.
common types of plants layout with their
Q.5 List any one principle of good layout.
advantages and limitations.
Q.6 Define maintainability.
Q.36 Explain in detail about maintenance procedure
of belts. Q.7 What is downtime.
Note: Very short answer type questions. Attempt any Q.22 What is overhauling.
ten questions out of twelve questions.
SECTION-C
(10x2=20)
Note:Short answer type questions. Attempt any eight
Q.11 Define testing.
questions out of ten questions. (8x5=40)
Q.12 What is vibration damping?
Q.23 Differentiate between breakdown maintenance
Q.13 What is process layout. and preventive maintenance.
Q.14 List equipments used for the alignment Q.24 What is the need of vibration isolation?
inspection of machine tool. Describe any one method of vibration isolation.
Q.15 State the benefits of reliability analysis in Q.25 Explain alignment and acceptance test of
industries? machine.
Q.16 Define the term failure. Q.26 Write short notes on Industrial safety rules.
Q.17 State the factors affecting maintenance cost. Q.27 Explain service life of machine tool.
Q.18 Differentiate between centralized and Q.28 Describe the procedure of periodic inspection.
decentralized maintenance.
Q.29 State the activities to be done in fault tracing.
Q.19 Explain primary function of maintenance
Q.30 Write procedure of formulating maintenance
engineering.
schedule.
(2) 127265/31765 (3) 127265/31765