Professional Documents
Culture Documents
Mario Kart Arcade GPDX Namco Manual
Mario Kart Arcade GPDX Namco Manual
MARIOKART ARCADE GP DX
Operation Manual
First Edition Published in December 2013 The actual product may differ slightly from the illustrations in this manual.
To ensure safe operation of the machine, be sure to read this Operation Manual before use.
Keep this Operation Manual in a safe place for quick access whenever needed.
# &" " " &() * +# # "
$ #/ "/# %# /& # # * ## # (
These must be performed by technicians only.
3 & " # " + # + # + #
# #" # + & " # &
# # #! ' #" "
&# *& " & # #+ & # &
1 & ## ## & & " # (
Test Mode
Troubleshooting
1
1. Safety Precautions – Be sure to read to ensure safe operation –
Should an abnormality occur, turn off the power switch immediately to stop
operations. Then, be sure to disconnect the power cord plug from the outlet.
accident.
Sections of the LCD monitor remain at a high temperature and high voltage
even after the power switch is turned off.
To avoid electric shock or burns, be careful not to accidentally touch these
sections.
!"
regularly and remove any dust.
Fully insert the power cord plug into the outlet. Poor contact may generate heat
!
# $ $!
Be sure to observe the following.
% & !
% !
% !
% !
% !
% !(Always unplug by holding the plug and not the power
cord.)
% ' !
%
devices or the wall.
% !
Do not expose the power cord and power cord plug to water. It may result in
electric shock or electrical leakage.
Do not touch the power cord plug with wet hands. It may result in electric shock.
The power capacity of the machine is AC 120 V (or AC 230 V), 3.2 A. To prevent
$#
!
Use a power supply voltage range of AC 110 V to 130 V (or AC 230 V). Using a
* $!+ *#
ensure that the machine operates in the optimum condition, keep the voltage
at AC 120 V (or AC 230 V) as much as possible.
To ensure safe use of the machine, be sure to perform the pre-operation
/45 " 67 * /
89!;* <=7 > !
inspections or service may result in an accident.
? * / 7
by our company. To order parts, contact your distributor.
Do not modify the machine without permission. Do not perform any operations
that are not described in this Operation Manual. Modifying the machine may
create unforeseen hazards.
If you decide to transfer the ownership of this machine, be sure to provide this
Operation Manual with the machine.
2
1. Safety Precautions – Be sure to read to ensure safe operation –
The warning labels contain important information for ensuring safety. Be sure
to observe the following.
%
visible, install the machine in an appropriate location with ample illumination,
and keep the labels clean at all times. Make sure that the labels are not hidden
' !
% * !
% " E * #
new one. To order warning labels, contact your distributor.
WARNING
The seat moves forward and back, and may pinch your
fingers or other items. Do not touch the gaps between
the seat unit and the main base or surrounding areas.
Test Mode
3
Table of Contents
# " #
1. Safety Precautions – Be sure to read to ensure safe operation –............................................................................1
>?>@ & .................................................................................................................................... 1
>?A 2# $ % ................................................................................................................... 1
>?D #&E # # ................................................................................................................ 2
>?G H @/ &................................................................................................................... 3
/& # #.................................................................................................................... 4
A(E 2# ..................................................................................................................... 8
D( # # ............................................................................................................ 10
G( &&E# # ! #5 ' ........................................................................................ 12
L( & "#&&# "# ................................................................................. 13
L?>#&&# "# ..................................................................................................................... 13
L?>?>#&&# @ # # " ..................................................................................................................................13
L?>?A&M # #&& " .........................................................................................................................14
L?A 1 " # & # !E " " ' ................................ 15
Q( " # .................................................................................................. 16
Q?> !# E 0& ' ........................................................................................................... 16
6-2 Transporting .................................................................................................................................... 17
Q?A?> # &&!E E# ' ................................................................................................17
6-2-2 Transporting on a Vehicle .........................................................................................................................................18
4
Table of Contents
5
Table of Contents
6
/& # # Test Mode Troubleshooting
7
Table of Contents
MEMO
!;
!>'# " * & >A^w>^[!L^ZQ^)x'ZAD^[w>^[!L^ZQ^)x'
!A'# " * # LR^H
!D'X # # G(RLZA(G
!G' # @ # !GA?'
!L' * #&& " H"#!H'G^(GRQ%z" #!'QD%z #!)']D(R%
103 cm 160 cm 238 cm
238 cm
93.7”
40.476” 63”
103 cm 160 cm
8
!;
190 cm
74.8”
40.476” 30.3”
103 cm 77 cm
E 2#
E # /& H"#!H'AA%z" #!'DD(]%z #!)'L>(A%
56 cm 86 cm 130 cm
130 cm
51.2”
22” 33.9”
56 cm 86 cm
Test Mode
36.1” 12.3”
91.8 cm 31.2 cm
Troubleshooting
!Q'H #
H #&& " X(L^Q&/ AD^(
H " /& "
0 # /& X(G^A(Q&/ >\D(
E # /& X(]Q(\&/ GG(
E/ " /& X(Q(Q&/ D(
9
3. Package Contents
Make sure that all the items below are contained in the product package.
If any items are missing, contact your distributor.
o.
va 4
E
ni e R ) 20
e
up
ph
61 k
MA
co
ca ep
nc (0
p
01
+4
po
.u
l Se la 83
RIO
rt
rv cem 61 :
KA
(E
ic en
C (0
RT
e/
+4
on )
ur
W t
4
su 20
C
op
AR
ar Pa
op
m 83
24
ra rts
e)
CA
ab 24
ie
nt :
+4 man ou /b /n
s
le
DE
y
4
of
20
Pa 61
(0
w tech
GP
th fro .c ua
Fa 83
w
rts 02
e m o.
w. ni
20
x: 24
DX
na ca
m l-m
Op
ua w re am
co an
l ca eb ntel co
era
61
r
26
n te ec tm
tion
uk ls
be : tro l
si
Ma
do
w
nua
nl
oa
l
de
.h
ni
d
c/
Fir rt No
st :
Pa
Ed HD
iti 45
on -10
Pu 48
bli 9-0
sh
ed 1
in
De
ce
mb
er
20
13
M
A
R Op
NA
MC
IO e
O BA
K rat
ND
A io
AI
R n
Ga
me
T M
s Inc
A a
.
R n
C u
A a
To ep
D l
en this
Ke
su Op
E
The
re er
act
sa ati
ual
G
fe on
pro
op Ma
duc
P
er
ati nu
t ma
on al
D
diff
of in
er
th a sa
slig
X
e fe
htly
ma
from
ch pla
ine ce
the
N
il u
, be for
A
stra
M
su ick
tion
C
re
s
in
O
to ac
this
qu
re ce
B
ma
ad ss
nua
A
th wh
l.
N
is en
Op ev
D
er er
A
ati ne
IG
on ed
Ma ed
am
nu .
al
es
be
fo
In
re
c.
us
e.
2 Service key (FRONT) 2
4 Cashbox key 2
6 Communication cable 5m 1
9 Title panel 1
10 Torx bolt M5 x 16 8
11 Connection bracket 2
17 USB dongle 1
18 Power cord 1
*1 Keep any unused contents routers in a safe place to avoid losing them.
*2 The quantity noted in the table above is the quantity per 2 ~ 4 machines.
# # Test Mode Troubleshooting
11
3. Package Contents
MEMO
4. Overall Structure (Part Names)
Front
Top cover
LCD monitor
Steering assembly
Rainbow PC board
(monitor side)
Seat assembly
Control cover
Service door
Slide unit
Rainbow PC board
Pedal assembly (seat)
Rear door
Power cord
12
<! * " J
&
<" J
The machine is designed for indoor use. Never install the machine outside or
in the following locations.
%Y E
%Y E $
%Y
%Y
%Y
%Y
%Y E
%Y E
%Y E E _
%Y E *
Test Mode
Troubleshooting
13
<! * " J
Create a play zone around the machine so that the player does not make contact
with bystanders or passersby.
78.7” or more
19.7” or (200 cm) 19.7” or
more more
(50 cm) (50 cm)
19.7” or
(50 cm)
more
82.7” or more
(210 cm)
Wall
Play zone
149.6” or more
(380 cm)
19.7” or 19.7” or
more 3.9” or more (10 cm) more
(50 cm) (50 cm)
19.7” or
(50 cm)
more
82.7” or more
(210 cm)
Wall
Play
zone
14
<! * " J
&
"#&&# "#
74.8”
190 cm
22”
56 cm
40.476”
30.3” 103 cm
77 cm
51.2”
Front assembly 130 cm
Test Mode
Troubleshooting
33.9”
Seat assembly 86 cm
15
\!> *
Do not leave the machine on a slope. It may fall over or cause an accident.
16
\!> *
\
\ > /;J ; 7
Before transporting the machine manually, be sure to separate the front as-
# # *' -
*!/;8YY <<!7
machine (such as carrying it on stairs) while it is fully assembled may result in
an accident.
When transporting the machine manually, be sure to use the following number
!* '!
%] / E!j6!\8Z$7~ 8
%; / E!=\!8jj$7~
17
\!> *
Before transporting the machine on a vehicle, be sure to separate the front as-
# # *'
to their highest level.
Transporting the machine while it is fully assembled may result in an accident.
When using a fork lift to transport the machine, observe the following. Failure
to observe the following instruction may result in an accident, such as the
machine falling over.
%>$ !
When transporting the machine manually, be sure to use the following number
!* '!
%] / E!j6!\8Z$7~ 8
%; / E!=\!8jj$7~
Seat assembly
Front assembly
18
4!
Should an abnormality occur, turn off the power switch immediately to stop
operations. Then, be sure to disconnect the power cord plug from the outlet.
accident.
!"
regularly and remove any dust.
Fully insert the power cord plug into the outlet. Poor contact may generate
!
Before operating the machine, be sure to check that installation has been
/<!
Delivery and Installation Conditions, page 13) in this Operation Manual.
] # $#
' !
The warning labels contain important information for ensuring safety. Be
#
sure to observe the following.
%
clearly visible, install the machine in an appropriate location with ample
illumination, and keep the labels clean at all times. Make sure that the
' !
% * !
%" E * #
new one.
To order warning labels, contact your distributor.
To ensure safe use of the machine, be sure to perform the pre-operation
/45 " 67 * /
89!;* \=7 > !
inspections or service may result in an accident.
If players start feeling ill because of the game images or light stimulation,
Test Mode
19
4!
9 # 4; " /9
5 7 6!
_ * ' !
9 #$<" ^ Y*
Z! _ * ' !
Operating the machine while parts are broken, damaged or deteriorated,
*# '
or a bystander. If you discover an abnormality, replace the affected part
immediately. To order parts, contact your distributor.
!>' &&* &/ && !E $>?G H @/ &% D('
!A' &&* &/ && /& !E $>?G H @/ &% D('
!D' &&& &"4 # "4 # " &!E $\?>?A ## 0 # /&
# # E # /&"@ &"4 # "4 # #% LR('
!G' # 2 "&x " "!E $L?>?A&M # #&& " %
>G('
!L' # * "" # /& &" # & # *&& #
& # # # # #
!Q' # * " & # "# # #& #"# "/ X /& #
/ ## # !E $\?A?D ## * "" "%
QQ('
!R' # * "& " #!E $\?A?D ## * ""
"% QQ('
!\' &" " # # # /& "
## && *# # # # * *#( " / &-
#+# # * *# "# &# # # ( +" ## *
cord plug from the outlet and contact your distributor.
20
4!
# && *# # " (!E $R?G?A"4 # #E*# % AL('
#
Test Mode
Troubleshooting
21
4!
4Z5 [
Game Overview
# && * # ?& "[E &/
# & (& # #" / # " ##
( & # # /# # & # * ? #
* # " # " # *## & &## &*# (
" &/& # # &/ / &-
( # & ?& 5 " +# * & ? " +
"[EYE " #* # & ! #* & #/
* & [EYE " '(
#
#-## #( 0 # "# ## +"#
0 #&## #* #### #(!0 # # &/& # Y
# ('
H # #* & # & # " *# #& #
# +0 " &" # "(
&"& #& " "### Y# (! 0 "
&" # # &/& # Y# ('
VERSUS mode (2-player to 4-player game * In case of two players this is displayed as
Two Player VERSUS mode.)
" && *& *## # # # (
& # " " "/4 # # (#* #
/ # +# & # "(
Auto-Accel function
/& &" * # &&# # & # "&# &#
+&& " # # ? & # ## # #&&# # #
#* # & # "& # " " (
"&# $ # ? & %" # & # (
# & # "& # / "& "+# # ? & #
Test Mode
canceled.
23
4!
Service door
Power switch
ENTER SELECT
SERVICE TEST
000000 000000
COIN BILL
Do not turn the power switch on and off repeatedly, because it may cause a
machine malfunction.
24
4!
Service door
ENTER SELECT
SERVICE TEST
#
000000 000000
COIN BILL
# & ## ##! & '*## & #*#+ #/ ## #
enter or execute the selection.
Troubleshooting
25
4!
# #&& X # &?# ## # * # " (H #
* *## " +# &?# # # # ( /&
"+# "&# # # ##& (/ &# "+
message is displayed on the monitor and the machine stops operating.
H "& "+ # $\W?A /& #% R^"
cancel the error.
I/O CHECK OK
NAMCAM (CAMERA) CHECK OK
STEERING CHECK CHECKING…
Self-test screen
Do not touch the steering wheel while the self-test is underway. If the steering
wheel is moved, the machine may display an error message and stop operating.
26
4!
#
(a)
Title screen
(b)
3 # # "# 5W@5( #/
# " &# "# + $\W?D!>'5 #* %
RD" & # /& (
(b) Display when game play includes credits added using the Service switch
& # !E'# X#"& "## & * # # ##& "-
# * # && " "#"" " # E *#(
Text color Description
H# #& " "#"" " # E *#
" & " "#"" " # E *#
Test Mode
Troubleshooting
27
4!
4<Z; ?
Once the software update preparations have started, do not turn off the power
switch until the update is complete and the title screen appears on the monitor.
+!
H #* "# "# " # #* " # &?# #+#
"&# $5Y% "" *& "# "#
"#( # # # #&&* # " *& " & # (
MARIOKART ARCADE GP DX PCB BOOT UP
Rev.1.00.00/EX ⇒ Rev.1.01.00/EX
# # / ## # # #"# X (H "# X & # +
# # #&& # #" * # # "#(
#
PLEASE CHECK
GAME SERVER REVISION
CONNECT CHECK NUMBER ON THE TITLE SCREEN AFTER UPDATE.
PLEASE DON'T TOUCH A STEERING WHEEL
MK3 Rev.1.00.00/EX
# # "# & # + # #* / # ##& (
Test Mode
29
4!
30
4!
4\ >
4\>?;
Y # & " # # " (
H # #*# ## 5+# 5Y # # (
!E $R?G?A"4 # #E*# % AL('
0&# E & #*# "" *# & ## # (
The selected item blinks.
# # *## # # & # "# (
H # & # # "+# # ### (
# 2&&# "4 # #+ ## #*## ( "& # #
the game screen.
#
MENU (DRIVE UNIT)
(a) COIN OPTIONS
(b) GAME OPTIONS
(c) I/O TEST
(d) MONITOR TEST
(e) SOUND TEST
(f) NETWORK TEST
(g) BOOKKEEPING
(h) OTHERS
(i) RELOAD NBLINE POINTS
(l) PCB ID : 1
(m) SOFTWARE VERSION: MK3100-3-NA-MPR0-A01(Rev.1.00.01/EX)
(n) SERIAL NUMBER: 012345-012345
MENU screen
Test Mode
Troubleshooting
31
4!
Reference
Item Description
section
!' 55E #" # ## See 7-6-2.
!/' 5E # #" 1 # ## See 7-6-3.
!' ZE E*#+&#" # ## See 7-6-4.
!"' 5E "&# # "4 # # ( See 7-6-5.
! ' EY5E [ & "4 # #+ #( See 7-6-6.
!' 5HE 5 #* &# " ## See 7-6-7.
!' W5 This displays play conditions and error log See 7-6-8.
!' )E E ###&x# + #( See 7-6-9.
!' @5W@55E &# @5W@55E ( See 7-6-10.
!4' 55EE H # " # # "+&& "#
! '" "#" + #"&
# / "#" "# 4 #
/ # " # # (
!' [YE55E5 "&# & "# !EYE+
E[EYE'4 #/ # " # # (
!&' W "&# W( See 7-6-3.
!' E0H[E5 "&# #* " / (
!' E@5YW "&# & / # # "YEW
" & (H # & / #/ "& "+
$?% (
! ' & Z "# # & Z ## ( See 7-5-4.
32
7. Operation
In the MENU screen, select COIN OPTIONS. The following screen appears.
# &&# # +# E & #*# " *# & # "
press the Enter switch to return to the MENU screen.
Operation
EXIT
*1 When FREE PLAY is set to ON, all other COIN OPTIONS items appear grayed-out and cannot be selected. (The
settings are held.)
When FREE PLAY is returned to OFF, operation returns to the held settings.
Test Mode
Troubleshooting
33
4!
PCB ID : 1 (b)
EXIT
34
4!
#
# * &(
!"' 0YE55 /& "/& 5! ' (
!'1 5 3Y 5! ' 5
00 3 # 5! '
# 1 ### 1 &?# # "# "/># #/& / (
Test Mode
Troubleshooting
35
4!
EXIT
Item Description
!' EH)E "# # # *#"/ ## (
!/' @E This screen is used to test the lighting of illuminated buttons and
" # &#(
!' Z05@M "# #&x # & # # # (!E $R?Q?>>
"4 # ## # & #!Z05@M'%
LD('
!"' 5!'E "# # #5! '(
! ' ZW "&# ZW # ## (
55! '3 # / " &&(
555! "'3 # #/ " &&(
# ZW # (
36
7. Operation
Operation
EXIT: SELECT SWITCH (UP) + ENTER SWITCH
Item Description
(a) COIN 1 Status of coin switch 1
Each time the switch 1 is activated, the counter increments by one.
000 to 999 (The counter returns to 000 after 999.)
(b) COIN 2 Status of coin switch 2
Each time the switch 2 is activated, the counter increments by one.
000 to 999 (The counter returns to 000 after 999.)
(c) SERVICE SWITCH Status of Service switch
OFF : Normal
ON (red) : Pressed in
(d) TEST SWITCH Status of Test switch
OFF : Normal
ON (red) : Pressed in
(e) SELECT SWITCH UP/DOWN Status of Select switch
OFF : Normal
ON (red) : Flipped up or down
(f) ENTER SWITCH Status of Enter switch
Test Mode
OFF : Normal
ON (red) : Pressed in
(g) STEERING WHEEL Status of steering wheel
Turning the steering wheel to the right changes the numerical value
in the positive direction, and turning the steering wheel to the left
Troubleshooting
37
7. Operation
Item Description
(h) GAS Status of accelerator pedal
Stepping on the pedal changes the numerical value in the positive
direction.
OK (red) appears on the screen near the setting limit. (* Note)
(i) BRAKE Status of brake pedal
OFF : Normal
ON : Stepped on
(j) ITEM BUTTON Status of Item button
OFF : Normal
ON (red) : Pressed in
(k) MARIO BUTTON Status of Mario button
OFF : Normal
ON (red) : Pressed in
* If OK is not displayed when the steering wheel/pedal is turned/depressed fully, the steering wheel or pedal must
be initialized. (See “7-6-11 Adjustments after Parts Replacement (GO TO I/F INITIALIZE)” on page 53.)
Flip the Select switch up and press the Enter switch to return to the I/O TEST screen.
38
7. Operation
UNDER LAMP ON
EXIT
Operation
SELECT SWITCH : SELECT ENTER SWITCH : ENTER
Item Description
(a) ITEM BUTTON LAMP Lighting status of Item button light
OFF : Off
ON (red) : Lighted
(b) MARIO BUTTON LAMP Lighting status of Mario button light
OFF : Off
ON (red) : Lighted
(c) SIGN Lighting status of signboard, monitor side lamp and under lamp
(d) MONITOR SIDE LAMP OFF : Off
(e) UNDER LAMP RED : Lighted red
GREEN : Lighted green
BLUE : Lighted blue
WHITE : Lighted white
PATTERN 1
PATTERN 2
PATTERN 3
Lighting variation patterns
PATTERN 4
Test Mode
* Lights that are lighted turn off when the LAMP TEST screen is exited.
Troubleshooting
To return to the I/O TEST screen, select EXIT and press the Enter switch.
39
4!
CALIBRATING FACIAL
RECOGNITION RANGE
LEFT RIGHT
3
FACIAL RECOGNITION
LEVEL
EXIT 0
Item
Setting value variable range Default
(Facial recognition range)
#Z& #"4 # # -15 to +15 0
40
4!
#
CROSSHATCH PATTERN (b)
FULL WHITE (c)
SCROLL PATTERN (d)
EXIT
Item Description
!' 55 Displays a gradation pattern.
!/' EE))5 Displays a crosshatch pattern.
!' 0Y@@H) &*# (
!"' E@@5 Displays a screen scrolling test pattern.
Test Mode
Troubleshooting
41
4!
VOLUME SETTINGS
GAME : 10 (a)
ATTRACTION : 10 (b)
EXIT
42
4!
#
* The test sound is produced from the speakers
in order.
A E@!'
D E@!'
Test Mode
Troubleshooting
43
4!
4\4|}&;
"# # ## #* # (
EXIT
Item Description
!' 5HEYE "# # #* ## """ +"
# 1 # #* ## (
!/' @@5H) "# # # # # & & #* (
!' 5@55H) "# # # # # & #*
check.
!"' Y) This screen is used to check the update status.
The connection status cannot be checked during server service periods, so avoid
server service periods when performing the network status check and the online
network check.
44
4!
NBLINE LICENSE OK
UPDATE SERVER LINK OK
GAME SERVER LINK OK
IP ADDRESS 000.000.000.000
SUBNET MASK 000.000.000.000 (a)
GATEWAY 000.000.000.000
VENUE ROUTER 000.000.000.000
PRIMARY DNS 000.000.000.000
SECONDARY DNS . . .
#
PCB ID : 1
SOFTWARE VERSION : MK3100-3-NA-MPR0-A01(Rev.1.00.01/EX)
SERIAL NUMBER : 012345-012345
SELECT SWITCH : SELECT ENTER SWITCH : ENTER
Item Description
!' 5 #* ## "& && *# "& "(
5W@5@5E35W@5 #2# &#
YE[3 # ## *# "#
E[3 # ## *#
EE3"" # / #
EYW5E3E / # ## &
H 3"" # *
[5YY3"" [5Y #
5E3"" 5E
E5 5E3"" " 5E
!/' 5W@5E5 &# 1 "" 5W@5 #2#
!' Y55HEYE # && * # (
1 # 5E")"" +# "#
time
5W@5 #2#
#
Test Mode
# # # 5HE + & # " # # *#(
Troubleshooting
45
4!
/7^JY^|}&J+J&
"# # # # # & & #* (
CHECK START
EXIT
PCB ID : 1
SOFTWARE VERSION : MK3100-3-NA-MPRO-A01(Rev.1.00.01/EX)
SERIAL NUMBER : 012345-012345
Item Description
!' W@) * # # # /& # "# #
/ "(
!/' [5YY) * # # # # # /& (
!' 55Y) * # # # # # # # /& (
!"' EY¢E)5YW # / # # "/ #* # "
# # (
When the communication cable is connected correctly, there are the two routers of
* # +5J? !
| +5J? Z #$
connected. Additional routers may result in communication errors.
46
4!
/7^"|}&J+J&
"# # # # # & #* (
CHECK START
EXIT
#
PCB ID : 1
SOFTWARE VERSION : MK3100-3-NA-MPR0-A01(Rev.1.00.01/EX)
SERIAL NUMBER : 012345-012345
Item Description
!' E[E5E # # " ##
* # # /& *# # (
!/' @EE5 # #& # " ## * #
# /& *# # (
The connection status cannot be checked during server service periods, so avoid
server service periods when performing the online network check.
Test Mode
Troubleshooting
47
4!
/7?5YJ+J&
This screen displays the update status.
EXIT
PCB ID : 1
SOFTWARE VERSION : MK3100-3-NA-MPR0-A01(Rev.1.00.01/EX)
SERIAL NUMBER : 012345-012345
# # # 5HE + & # " # # *#(
Item Description
!' 5W@5Y)55EYE &# 5W@5 #2# ## (
!/' YE[Y)55 &# "# #2# ## (
!' EYE0H[( &# #* ## # (
!"' @5E5H@E0H &# * # &/& "# (
! ' H5@5[( &# * # / " *& " "(
!' H5@EE &# !£'*& " *& " " *(
!' E0HYE &# # #* "# ## (
48
4!
#
Test Mode
Troubleshooting
49
7. Operation
PCB ID : 1
EXIT
Item Description
(a) REFORMAT OPTIONS Used to initialize settings.
(b) SOFTWARE VERSION Displays the software version.
(c) SOFTWARE REVISION Displays the software revision and the update date and time.
(d) SERIAL NUMBER Displays the serial number of the USB dongle.
(e) LANGUAGE Displays the language setting.
50
7. Operation
In the OTHERS screen, select REFORMAT OPTIONS. The following screen ap-
pears.
Flip the Select switch up and down to select the item. The selected item blinks.
Press the Enter switch to enter the selected item. The screen for the selected item
appears.
H #&x# 2 "+# E & #*# " *# & # "
press the Enter switch to return to the OTHERS screen.
Operation
(RETURN DRIVE UNIT BOOKKEEPING TO FACTORY SETTINGS)
EXIT
Item Description
(a) REFORMAT BOOKKEEPING Initialized contents (only within bookkeeping)
All bookkeeping data
All error log entries
(b) BACKUP MEMORY INITIALIZATION Initialized contents
Game options
Analog potentiometer initialize settings
Sound level settings
Remaining credits, remaining service credits
Test Mode
51
4!
4\6}^Y9^"5";
"&# 5W@55E "# (
EXIT
Item Description
!' 5W@5E[ &# # ## *## 5W@5E[(
!/' 55 &# "5W@55E(
!' )E[5E E & ### # # *## " #
5W@55E(
52
4!
#
/ "& # "('
# "# + # # *#(
& # *&&/ #&x "(
# # #&x# & # +# EH)E ! $R?Q?G!'EH)
E% DR' ( # # * & &&# # #"# &&#
# & #+" ##)"@0 "& " # (
0 &&" # & # "&+" ##"& " #
for each.
0&# E & #*# " # # *## # # # ZE (
STEERING +031
GAS 030
53
4!
44 J
Do not use alcohol or other organic solvents. This may degrade the materials.
54
8! > — Must be performed by a technician —
8Y!" Y
8Y!Y
8Y" ; Y
55
8Y!" Y
Title panel
56
8Y!" Y
4 #/ # # # "" # # /& *#
2 # & #(@ # / &# ## / #+ # / #" ##
# # *& # * "!* # #' *# 2
# #( ## # / &#""" "/ &# # ## *(
0 #&&# +# / &#!\XD^# X/ &#'/ #&& "/"&
gap slightly larger than thickness of the bracket and then the bracket can be installed
/&# & & # / # # / &#"# &"# / #
*# * "# & ( & ## # #* (
Seat assembly
Torx bolt
(M8 x 30)
Flat washer
(ø9 x 30 x t2.3)
Connector
Test Mode
Flat washer
(ø9 x 30 x t2.3)
Front assembly
Torx bolt (M8 x 30)
Troubleshooting
& # # /& # # /&+" && ##* #
inside the front assembly.
&& # #* # " # # /&+ " # # # #
connector from step .
57
8Y!" Y
## 4 #/ ## # # /&(H& ## #+/ &
not to pinch the connectors or harness.
0 # " # # /&+# # # /&# # # /&
*##* #* !¥]XD^X#A(D' " ! # #&'"#* # X/ &#!\X
D^' " ! # #&'(
@ * # & &"4 # #&# # # # X(^(A%!^(L' # (
!* # # /&"#* # # /&¦ # #&('
Approx.
Level adjuster 0.2” (0.5 cm)
Caster
58
8Y!" Y
The USB dongle is for use exclusively with this machine. Do not use it with
other equipment. Do not insert other USB dongles into this machine. Doing so
may cause the machine to malfunction.
Be sure to turn off the power switch before inserting the USB dongle.
Rear door
Test Mode
Troubleshooting
59
8Y!" Y
## YEW" & # # YEW& # # / "! # 2
/ & *'(
Game PC board
USB dongle
USB dongle
60
8Y!" Y
* $# ' #
damage to the electronic circuits, be sure to turn off the game cabinet power
switch before starting work.
9 '
E !"
electric shock.
Lay out the communication cables safely so that they will not cause players,
bystanders or passersby to trip over them.
61
8Y!" Y
8YJ
* $# ' #
damage to the electronic circuits, be sure to turn off the main power switch
before starting work.
# # 2 / & *+" ## & " # " #
cables.
W # ## # /& # W "# # # #
# # ##/& # #(
Y# / # "# & # # # (
# * 1 " #* # " "# #
"# # #&&# & # ( +# # &" /
outline of the connections.
0 1 "" " & ## #&&# & # + ##
distributor.
Communication cable [1 m]
(supplied with the machine)
Contents router
(supplied with the machine)
62
8Y!" Y
8YJ >
Game PC Board
LAN port
Test Mode
Troubleshooting
63
8Y!" Y
# # # /& !L'# Y? " #? # # & * &+
and return the rear door to its original position.
Game PC Board
Communication cable
U-shaped cut-out
### " (
## * "& # # * &4"# # /&
!L'# # @5 # # & " # # # (
Communication cable
WAN port
used for connection
to the machine
Not used
Communication cable (1 m)
used for connection Power supply jack
to the NBLINE router Power cord plug
## # /& !>' " # # # 5W@5 # !#
# # "# 5W@5'# # H5 #(
64
8Y!" Y
Check the shape of the communication cable connectors and insert them with the
proper alignment.
" !" #
communication will not operate properly.
J
are not stretched and there is no excessive force applied.
65
8Y!" Y
Be sure to install the ground wire using one of the methods below.
Failure to install the ground wire may result in electric shock.
Connect the ground using a 3P plug.
66
8Y!" Y
Service door
Power switch
ENTER SELECT
SERVICE TEST
67
8Y!" Y
8YZ!; 5J9"
H ##* # # ?& "[E &+
# && * ##(
PCB ID : 1 (b)
EXIT
##!'5YW055[Y5E# # /
# && # " / #*## * # " (
E #!/'W# $>+%$A+%$D%"$G% " # & # #/ #(
H # / ## W+
appears.
E ## #*## 00"& # " (
68
89!;*
* $# ' #
to turn off the power switch before performing service work (such as repairs
or correcting malfunctions).
E
89" "
>( ### & &"4 # 2X " &(!E $\?>?A ## 0 #
/&# # E # /&"@ &"4 # "4 # #% LR('
>( ### * "2 & # "# # - "/ X"# *
outlet.
A( & " # # " # # # #(
D( " # # * " (# / &# #
* "+/ # & #(
# && * # & (0 && ## & #(
Test Mode
69
8B. Service
8B-2 Troubleshooting
" # $
securely.
Repair of the PC boards will be performed by your distributor, so never perform a
continuity check of a board with a tester or any other tool. The IC may be damaged
by the internal voltage of the tester.
To order repairs or parts, contact your distributor.
When sending parts for repair, be sure to pack them properly. Particularly when
sending the Game PC Board, wrap the part in sponge or air bubble wrapping before
packing it in a cardboard box. Make sure that the box is not exposed to outside
pressure.
8B-2-1 General
70
89!;*
89] Y
Symptom Cause Action Reference
Sound is not output from the & ##& *( ## & ( Page 42
speakers.
# 0# # & ## # 0#
Page 93
disconnected. terminal securely.
/ "& # ( & # / "( Page 93
The monitor screen does not # " # "( ## # &( Page 79
operate.
# & # ( & # # ( Page 79
The title panel LEDs do not turn # " # "( ## # &( Page 87
on.
@/ !@'& # ( & # @/ !@'( Page 87
/ ## # / ## # " # "( ## # &( Page 78
does not function.
*#& # ( & # *#( Page 78
" # # ( ## & # #
disconnection.
E
& # / ## # " # "( ## # &( Page 78
# / ## " ## (
71
89!;*
89j5Y
89<; Y
Symptom Cause Action Reference
The LEDs on the back of the # " # "( & # # ( Page 98
seat do not turn on.
@/ !'& # ( & # @/ !'( Page 98
The LEDs on the back of the # " # "( ## # &( Page 101
seat base do not turn on.
/ *W " & # / *W "(
Page 101
malfunction.
72
8B. Service
E
05-04 IP ADDRESS ERROR
GG+L]
2 "# " "Q>
NETWORK AUTHENTICATION !# #'*# #*
05-54
ERROR # +
# # "(
73
89!;*
Error Reference
Error message Cause Action
code page
"# 1 " Perform the update required
NETWORK CONNECTION
6<<< operation has not been for operation.
UNSTABLE
performed.
/ &# # #*
# *## connection.
INITIAL NETWORK
6<<\ # 2 ## GG+Q>
Y?+"JY"}}}
# *# # "
after installation.
| #
then on again.
If the error persists, check the connections and operation of each part.
When turning the power switch off and then on again, wait 30 seconds or more
between operations to protect the electronic circuits.
74
89!;*
/Z7 +
Error Reference
Error message Cause Action
code page
*# & # *#(
malfunction. ## "# / # (
01-11 COIN ERROR1 (COIN UNIT1)
5?q[!'/ " & # 5?q[!'
Page 92
malfunction. board.
/ &## ## "# / # (
E *#(
01-12 COIN ERROR2
5?q[!'/ " & # 5?q[!'
Page 92
malfunction. board.
/&& &"# & # ( ## "# / # (
01-21 COIN ERROR1 (COIN UNIT2) 5?q[!'/ " & # 5?q[!'
Page 92
malfunction. board.
The time setting is ## "# / # (
66\ CLOCK ERROR1
incorrect.
W "
E
664 CLOCK ERROR2
malfunction.
cabinet.
Troubleshooting
75
89!;*
* $# ' #
damage to the electronic circuits, be sure to turn off the power switch before
starting work.
Rainbow PC Board
Top cover
76
89!;*
* $# ' #
to the electronic circuits, be sure to turn off the power switch before starting work.
# #* # X/ &#!LXAL' # # # # /&+"# X
# X/ &#!LXAL' " # # & (
E
- &
Torx bolt
(M5 x 25)
Item button,
Mario button
Connector
Item button
Test Mode
Control cover
Connector
Mario button
Troubleshooting
When installing the control cover, be careful not to trap the harness.
77
89!;*
# / ## " X& # && * " (Y #
" # & # / ## (
* $# ' #
to the electronic circuits, be sure to turn off the power switch before starting work.
Faston terminal
harness color: (white)
Illuminated switch
(N.O.)
LED lamp
Illuminated switch
78
89!;*
* $# ' #
to the electronic circuits, be sure to turn off the power switch before starting work.
The LCD monitor weighs approx. 22 lb (10 kg). Be very careful while working,
'!
E
- &
Torx bolt (M5 x 30)
Rear door
Connector
Test Mode
Troubleshooting
79
89!;*
Connector
Connector
80
89!;*
Camera assembly
Monitor glass
E
- &
Torx bolt (M5 x 25)
Monitor stopper (upper)
@# # # &&#&+ && ## / ## " # * " " #(
Monitor glass
Test Mode
Troubleshooting
81
89!;*
Torx bolt
(M5 x 25)
LCD monitor
LCD bracket
LCD monitor
LCD bracket
82
89!;*
* $# ' #
to the electronic circuits, be sure to turn off the power switch before starting work.
E
- &
Steering assembly
83
89!;*
Steering assembly
Cap bolt (M6 x 30)
Steering assembly
After completing the replacement, be sure to initialize and check the operation.
/;4\Y' 5 } /["]"""Y^"`7
<Z 4\j/7;|"J+; Z4!7
84
89!;*
* $# ' #
damage to the electronic circuits, be sure to turn off the power switch before
starting work.
E
- &
Monitor side BK (L)
Countersunk
washer nut (M4)
Connector
Rainbow
PC Board
Test Mode
85
89!;*
/47} J
* $# ' #
damage to the electronic circuits, be sure to turn off the power switch before
starting work.
Connector
86
89!;*
/87} ^9/^7
* $# ' #
damage to the electronic circuits, be sure to turn off the power switch before
starting work.
E
Torx bolt (M5 x 25)
Top acrylic
87
89!;*
89j] Y};
(1) Replacing the Game PC Board
* $# ' #
damage to the electronic circuits, be sure to turn off the power switch before
starting work.
Game PC Board
Countersunk washer nut (M6) Connector
Rack base
88
89!;*
E
- &
Game PC Board
Rack base
When sending a part for repair (Game PC Board), wrap it in sponge or bubble
wrap before packing it in a cardboard box. Make sure that the box is not
exposed to outside pressure.
After completing the replacement, be sure to check the operation and initialize.
/;4\ > Z!7
Test Mode
Troubleshooting
89
89!;*
When installing, follow the indications on the game PC board, and connect the
connectors correctly.
* &!& '
SERIAL 1
YEWD
YEW" &
! ## [>('
#X *## q[Z(
No connection
# /&
JV I/O
!/&YEW/& '
#X *# #
YEW/& (
" !©D(L# /& '
Black Orange
Yellow-green
90
89!;*
* $# ' #
to the electronic circuits, be sure to turn off the power switch before starting work.
To avoid damaging the electronic circuits, make sure that the connector direction
is correct when connecting the connectors.
The PC board is sensitive to static electricity. If a person handles a PC board while
charged with static electricity, the parts on the PC board may be damaged.
Before handling the PC board, discharge the static electricity from your body; for
example, by touching the surface of grounded metal.
E
# # X # + # EG !' / " # &
+" & #(
Locking spacer
Connector
Test Mode
Connector
After completing the replacement, be sure to check the operation and initialize.
/;4\Y' 5 } /["]"""Y^"`7
<Z 4\j/7;|"J+; Z4!7
91
89!;*
* $# ' #
to the electronic circuits, be sure to turn off the power switch before starting work.
To avoid damaging the electronic circuits, make sure that the connector direction
is correct when connecting the connectors.
The PC board is sensitive to static electricity. If a person handles a PC board while
charged with static electricity, the parts on the PC board may be damaged.
Before handling the PC board, discharge the static electricity from your body; for
example, by touching the surface of grounded metal.
Locking spacer
Connector
NA-JV (M)
PC board
92
89!;*
* $# ' #
to the electronic circuits, be sure to turn off the power switch before starting work.
To avoid damaging the electronic circuits, make sure that the connector direction
is correct when connecting the connectors.
The PC board is sensitive to static electricity. If a person handles a PC board while
charged with static electricity, the parts on the PC board may be damaged.
Before handling the PC board, discharge the static electricity from your body; for
example, by touching the surface of grounded metal.
E
and replace it.
Amp PC board
Locking spacer
Connector
Locking spacer
Test Mode
Troubleshooting
Connector
93
89!;*
* $# ' #
to the electronic circuits, be sure to turn off the power switch before starting work.
To avoid damaging the electronic circuits, make sure that the connector direction
is correct when connecting the connectors.
The PC board is vulnerable to static electricity. If a person handles a PC board
while charged with static electricity, the parts on the PC board may be damaged.
Before handling the PC board, discharge the static electricity from your body; for
example, by touching the surface of grounded metal.
# * *#(!E $\?A?G * E*# # " # *
E*#% QR'
# " (!E $\W?G?>!G' &# @ # % R]('
# # *+" ## # & # &# +
# #* && " *!*##" * GX>A'+" &
# *# &# !>A['(
Inside the Front Assembly Rear
GN/YE W!#'
OG W!#' WH
#&&+ # " ( # # 2 / #
terminal connection locations.
When connecting the ring terminals, check the harness colors and contact
conditions carefully to avoid damaging the electronic circuits.
94
8B. Service
your distributor.
Remove the rear door. (See in “8B-4-1 (4) Replacing the LCD Monitor” on page
79.)
Replace the fuse (5 A SB).
Test Mode
Troubleshooting
89!;*
89jZ5Y
(1) Removing and Installing the Pedal Assembly
* $# ' #
to the electronic circuits, be sure to turn off the power switch before starting work.
E! 8!8 ! 9 * $ #
'!
Connector
Pedal assembly
Pedal assembly
89jj; Y
* $# ' #
to the electronic circuits, be sure to turn off the power switch before starting work.
The slide unit and seat weigh approx. 33.1 lb. When laying down and removing
# ' !
Make sure there is no one in the surrounding area.
Seat Phillips Pan head screws (M5 x 25) Seat slide assembly
E
- &
Under cover
Seat assembly
* $# ' #
to the electronic circuits, be sure to turn off the power switch before starting work.
98
89!;*
Connector
E
# "&"# #* && " *!*##"
Cord clip
Connector
LED bar (S)
Phillips pan head screw
(with flat and spring washers)
(M4 x 8)
99
89!;*
Install the LED bar (S) so that the light emitters face the direction shown in the
!/| # !7
Light emitter
LED tube cap (L)
LED tube
Light emitter
When installing, take care to press the LED Bar (S) all the way into the guide in
the center of the LED tube cap (L) so that it will not come loose.
Guide
LED Bar (S)
100
89!;*
* $# ' #
damage to the electronic circuits, be sure to turn off the power switch before
starting work.
E
* E*#% QR('
Connector
Test Mode
Troubleshooting
101
89!;*
102
=!
When disposing of the machine, follow the applicable regulations for collection,
transportation and disposal.
When delegating the collection, transportation and disposal of the machine,
!
Disposal
Test Mode
Troubleshooting
103
10. Parts List
Parts List
15 Monitor stopper (upper) 1 XMK3-734-957
16 Monitor stopper (lower) 1 XMK3-734-958
17 Ventilation panel 1 XMK3-735-003
18 Monitor side bracket (R) 1 XMK3-735-023
19 Control panel under cover 1 XMK3-734-969
20 Game PC Board 1 SYS ES3 (A) ASSY ーーーー
21 LCD monitor 1 ーーーー
22 Led bar 600 1 XMK3-735-045
23 POP LED bracket 1 XMK3-735-029
24 Rainbow PC Board 9 SCU02-A XMK3-307-781
25 Corner cover (M) 2 XMK3-735-020
26 NA-JV (M) PC board 1 NA-JV (M) PCB (ROM) Assy ーーーー
27 Amp PC board 1 V389 C2-IS AMP PCB Assy ーーーー
28 Steering PC board 1 STR4 (M) PCB (ROM) Assy ーーーー
29 Coin counter 2 XMK3-734-985
30 Switching regulator (12 V) 1 RS-150-12
31 Switch (toggle) 1 XMK3-734-983
32 Switch (push) 1 PBS-10B XMK3-735-016
33 Switch (push) 1 PBS-10B XMK3-735-016
34 Switch (toggle) 1 XMK3-734-984
Test Mode
10. Parts List
Parts List
51 Top filter (M) 6 XMK3-734-973
52 Camera cover (M) 1 XMK3-734-975
53 LED bracket (L) 1 XMK3-735-024
54 LED bracket (R) 1 XMK3-735-025
55 Side sheet 2 XMK3-733-393
56 Fork sticker 2
*1 The quantity noted in the table above is the quantity per 2 ~ 4 machines.
10. Parts List
10. Parts List
Parts List
1 4 3
(Opposite side 2 )
Test Mode
Troubleshooting
10. Parts List
13
10
19
18
11
110
10. Parts List
Parts List
15 LED tube 300 2 XMK3-733-371
16 Base end sticker (M) 1 XMK3-733-387
17 Caster (adjustable) 3 XMK3-734-995
18 Adjustment bolt 4 XMK3-734-994
19 Adjuster bracket 4 XMK3-734-996
20 Tail lamp panel 1 XMK3-735-033
21 Tail lamp reflector 1 XMK3-735-034
22 Tail lamp cover 1 XMK3-735-019
23 Emblem 1 XMK3-733-369
24 Emblem sticker 1 XMK3-733-370
25 Rainbow PC Board 2 SCU02-A XMK3-307-781
26 Caution sticker Seat Slide (C) 1 XMK3-735-006
Test Mode
Troubleshooting
10. Parts List
10. Parts List
Parts List
4 Key 1 XMK3-727-782
5 Shaft 1 XMK3-727-784
6 Timing Belt 1 XMK3-727-804
7 Feedback Steering Assembly, all but 2 & 3 1
Troubleshooting
11. Wiring Diagram
)0;' )0;'
1)
(4106#55; $-
0#,8 / $- )0;'
)0&
$ 2%$ 41/ #55; #EVKXGUVGGTKPIYJGGN $
$-
)0&
4& 4&
8 8 %
75$ECDNG 4& $0 $0 9
,85 8 56''4+0)
4& $- $-
8 )0&
$- 5JKGNF
)0& /
1)
8
4& 㪫㪧㪅 㪫㪧㪅 4& 4&
/1614
$- $- $- /
/1614
$0 $0
,85 564A6:& 564A4:&
4& 4& $7
564A4:& 564A6:& #%8 .
)0;' $- $- )0;'
)0& )0& ()
5JKGNF 2-
#%8 0
75$ # <*4CFCRVQTECDNG
% 75$ %
564㧔/ 2%$㧔41/ #UU[
%#/'4#/1&7.'
4& 4& 4&
8 8
9* 75$&KUEJCTIG 1) 1)
Wiring Diagram
$-
& )0&
.6)0 JCTPGUU #55; $- $- $- $-
& 75$ )0&
$-
)0& 8 8
4& $- (/
5*'.. 㪩 )0&
㪪㪰㪪㩷㪜㪪㪊㩿㪘㪀㩷㪘㪪㪪㪰 1) 1) 4')
(/ $- $- 219'45722.;
#%8 . 89
#%8 0
1) 㪈㪈㪌㪭㪆㪉㪊㪇㪭㩷㫀㫊㩷㫊㪼㫃㪼㪺㫋㪼㪻
8 () ' ' 㪹㫐㩷㫊㫎㫀㫋㪺㪿
$- $- $-
)0& 4
. )0;' )0;' $-
52 #% .
& 㪭㪊㪏㪐㩷㪚㪉㪄㪠㪪㩷㪘㪤㪧㩷㪧㪚㪙㩷㪘㫊㫊㫐 &8+&ECDNG
ǾOKPKRNWI
9* 9* 9* &
52'#-'4 . 8+&'1 #% 0
4%#ECDNGYKVJ
$- )0;'
ǡ 9 ()
$0 $0 9*
52176A.
;' ;' )0;'
52176A.
)0;'
$7 $7
52176A4 8+&'1
86 86
52176A4 㪋㪉㫀㫅㪺㪿㩷㪣㪚㪛㩷㪤㫆㫅㫀㫋㫆㫉 ( (75' ( (75'
52 㪡㪍 㪩㪚㪘 8#Z 8#Z
$- $- $7 $7
52'#-'4 4 㩿㪣㪀 㪮㪟 #%8 .
ǡ 9 㪡㪎 㪩㪚㪘 #%8 0
㩿㪩㪀 㪩㪛 () ' '
6
$- $- $- 64#05(14/'48# $-
㪭㪠㪥 㪈㪇㪇㪭
)0;' )0;' )0;' )0;' )0;' $- $7
' '
)0;'
9* 9* 9* 9* 㪇㪭 㪇㪭 9*
)0;' 2-
#%%18'42.#6' $- $-
0QVG
)0;' )0;'
59 219'459
.+0' 01+5'(+.6'4 ( (75' 9* 9*
,+04'6
#%%CDNG $- $- $- $-
#% . .
9* 9* 9*
#% 0 0
)0;' )0;'
' ' () '
㪥㫆㫋㪼㩷㪈㪑㪫㫆㩷㫄㪸㫋㪺㪿㩷㫋㪿㪼㩷㪸㫉㪼㪸㩷㫋㫆㩷㪹㪼㩷㫌㫊㪼㪻㩷㫋㫆㩷㫊㪼㫋㩷㫋㪿㪼㩷㫀㫅㫇㫌㫋㩷㫍㫆㫃㫋㪸㪾㪼㩷㪭㪠㪥
Test Mode
219'4592.#6'
(;3/$1$725<5(0$5.6
( (75'
8#5.19$.19 +02768 /,1( $:* &2/257$%/(
( 8#5.19$.19 +02768 $:* %. %/$&. 97 9,2/(7 (
*1<(
%1 %52:1 *< *5$<
Troubleshooting
:,'( $:*
/,1( 27+(5&2/25 5' 5(' :+ :+,7(
$:*[[ $:*[[ 2* 25$1*( 3. 3,1.
<( <(//2: /7*1 /,*+7*5((1
$//&2/25 $:* 3$*(
1$552: *1 *5((1 /7%8 /,*+7%/8(
/,1(
$:*[[ $:*[[ %8 %/8(
ಯ&2/25&2/25ರVLJQHGVSLUDOFDEOH
11. Wiring Diagram
*1<(
*1<(
)5217$66<
%. &
:+<( : 2*
9
$ 5' 5' 5' /7*1 $
6&/.
:+ :+<(
/5
%8 :+5' 2* 2*
9 9 *1'
%. %. /7*1 /7*1 /7%8
6&/. 6&/. 6/$7
5' %. %.
9 /5 /5 *1'
%. 3.
*1' *1' *1' 6'$7B
:+5' /7%8 /7%8
%5$.( 6/$7 6/$7
%. %.
*1' *1'
3. 3.
6'$7/ 6'$75
3.
*1<(
6'$7B
2*
9
2* 2* 2* 2* 2* /7*1
6&/.
%8 %8 3. 3. :+97 3. 3.
% 6'$7/ 6'$75 /5 %
2* :+ 2* 2* /7*1 /7*1 /7*1
9 9 *1'
%. %. /7*1 /7*1 /7%8 /7%8 /7%8 /7%8
6&/. 6&/. 6/$7
675㸦0 %. %. %. %. %.
/5 /5 *1'
3&%㸦520 $VV\ *1<( *1<( 3.
*1' *1' 6'$7
/7%8 /7%8
6/$7 6/$7
*< 2* 2* %. %. *1<( *1<(
$B67((5 *1' *1'
%. 97 97 3. 3.
/7*1
/7%8
/7*1
/7%8
*1' 6'$7/ 6'$75
2*
2*
%.
2*
%.
/7%8 :+ :+
675B32:(5
%. %. 5'
%.
3. 3.
6'$7/ 6'$75
2* 2*
9 9
& 1$-9 0 2* 2* /7*1 2* 2* /7*1 2* 5' 5' &
6&/. 6&/.
3&% 520 $66< :+5' 3. :+<( 3. %. %. %. %.
/5 /5
/7*1 /7*1 /7*1 /7*1
*1' *1'
*< /7%8 /7%8 /7%8 /7%8 /7%8 /7%8
$B67((5 6/$7 6/$7
%. %. %. %. %. %. %.
*1' *1' *1'
5' *1<( *1<( 3. *1<( *1<( 3.
$B9 6'$7/ 6'$75
:+ 2*
$&&(/ 9
%. /7*1
*1' 6&/.
:+97
6'$7 /5
:+*<
6'$7 *1'
:+5' /7%8
6'$7/ 6/$7
2*
%.
:+<( %.
6'$75 *1'
/7*1 /7*1 /7*1 3.
' 6&/. 6'$7B '
/7%8 /7%8 /7%8
6/$7
%. 2* 2* 2*
*1'
%. %. %. %.
*1'
*1<( *1<( *1<(
6'$7B
2*
2*
*1<(
9
/7%8 /7*1
675B32:(5 6&/.
%8 5' 5' %.
%5$.( /5
2* 2*
*1' *1'
2* %. /7%8
,7(0B6: 6/$7
%8 *< *< *< %.
,7(0B/$03 *1'
0$5,2B6:
:+ 2*
2* 2*
㻯㻯 3.
6'$7B
97 %8 %8
83
%.
%.
( %. 97 97 (
*1' '2:1
5' *1 /7*1 %.
/7*1
/7%8
6(59,&(
2*
%.
2* %. %. 3.
7(67 6'$7B
*< :+*< *< *< 2*
9
83
%8 2*
2* 2*
㻯㻯 2*
2* /7*1
6&/.
97 *1<( *1<( *1<( :+*< 3.
'2:1 /5
*1 /7*1 /7*1
(17(5 *1'
:+*< /7%8 /7%8 /7%8
6/$7
2*
3. 2* 2* 5' 5' %. %. %.
&2,1 *1'
/7*1 3. 3. %. %. *1<( *1<( 3.
&2,1 6'$7
%. 3. 3. %. 5'
*1'
%.
2*
%. %. %.
2*
*1<(
) )
*1<( *1<( *1<( *1<(
2*
2*
%.
%.
/7*1 3. 3. *1<(
%. %. %.
Test Mode
2*
%.
2* 2* 2*
*1<( *1<( *1<(
%. %. %.
* *
Troubleshooting
(;3/$1$725<5(0$5.6
115
Copyrights and Trademarks
the operation of this machine.
game machine. Doing so may result in mechanical malfunction.
"#$%!&'
## (
! ( )*+,"#$%!&'-
#
license conditions and other information.
/012334
(&5607$%'580!##&''&(8
$8#&B%08#50&+8C%##CB$&/B%00%'6&%'6E'8,508##
&0
!518'(1/'7"/'&1!8&$8B%00%'8#&!80($%'%"16
'8##&0%5%0(/1%05/05%''&''0'78!8'&$05%06
07$#'
'&8+8'#$%11$8%/$&0#&0(&5607$$&180#"81%"18&0%'6
(1%!
%!%78#&0&$801%"16B$8$80'%'%(&'&(&'0%(&0&0
&$80B#8%0#'70&!&/&&0'(&''8(&'B$$8#&B%08&0
$8/#8
&0&$808%1'7#'$8#&B%08
8?
A
# F
=============================================================
( (< + ( # 8934
( )-344;3442
')' ( -% A
0
A H
90 A
30 A
I A
$##&B%08#50&+8"6'C%##C%'%'68,508##&0!518
B%00%'8#'(1/'7"/'&1!8&$8!518B%00%'8#&
!80($%'%"16%''8##&0%5%0(/1%05/05%08#(1%!8
''&8+8'#$%11'"81%"18&0%'608('08('(8'%1
#58(%18,8!51%06&0(&'#8J/8'%1%!%78#)'(1/'7"/'&
1!8&50&(/08!8'&#/"#/87&&#&0#80+(8#K1&##&/#8
%%&050&#K&0"/#'8##'800/5&'-$&B8+80(%/#8%'&'
%'6$8&06&1%"16B$8$80'(&'0%(#0(1%"16&0&0
)'(1/'7'87178'(8&0&$80B#8-%0#'7'%'6B%6&/&$8/#8&
$##&B%088+8'%+#8&$85&##"16&#/($%!%78
=============================================================
&##1949
A &##15 &##1
) HII I-
1(8'#8##/8#
===========
&##11
--------------------
IMNNNNNNNNNNNNNNNNNNNNNNNNNNNNNNNNNNNNNNNNNNNNNNNNNNNNNNNNNNN
M( )-9::O<3499&##15 % A
*
M0
M A
* are met:
*
M90 A
M
*
M30 A
M
M I A
* distribution.
*
M*% A
M H
MC A &##15
M &##1 ) HII I-C
*
MR C&##1 C C&##15 C
M A
M
M< >
*
MS5 A C&##1C
M C&##1C
M &##15
*
M;0 A
M H
MC A &##15
M &##1 ) HII I-C
*
M$##&B%08#50&+8"6$8&##150&T8(C%##C%'%'6
M8,508##8&0!518B%00%'8#'(1/'7"/'&1!8&$8
M!518B%00%'8#&!80($%'%"16%''8##&0%5%0(/1%0
M5/05%08#(1%!8''&8+8'#$%11$8&##150&T8(&0
M#(&'0"/&0#"81%"18&0%'608('08('(8'%1
M#58(%18,8!51%06&0(&'#8J/8'%1%!%78#)'(1/'7"/
M'&1!8&50&(/08!8'&#/"#/87&&#&0#80+(8#K
M1&##&/#8%%&050&#K&0"/#'8##'800/5&'-
M$&B8+80(%/#8%'&'%'6$8&06&1%"16B$8$80'(&'0%(
M#0(1%"16&0&0)'(1/'7'87178'(8&0&$80B#8-
M%0#'7'%'6B%6&/&$8/#8&$##&B%088+8'%+#8
M&$85&##"16&#/($%!%78
* ============================================================
*
M 8 6
M) > -
M$ ) > -
*
MI
Use. A Z
6 A
!'"7 A 6
use.
b. Other Software.6
Y [ A
Y A <A
Y # A
A
A A
A
c. Device Connections.6 A
A
6 A A A
6 A
Y # A
Y 5 # A
Y # A
Y ( # # A
A \ ?]
6
A (5I5
d. Remote Access Technologies.6
A
0 A A
0 %\] ?
& A A
& %6 0 %
A
& 0 /6 A
A( 0 %
A F A
e. Font Components.B
6
Y K
Y A
f. Icons, images and sounds.B
" # % [+ $
)\+$ ]- < A+$
A +$ A
+$
4. POTENTIALLY UNWANTED SOFTWARE. B B
A \ ]\ ]
)Z - A % \] \A ]
A 0A
Y & A
Y 6 A
" A
$ % & A
'"7 ! A / A
?
'"76 H
Y K
Y A K
Y K
Y K
Y K
Y A
8? ? A A
A ! !
A A
' ( # ! A < A
!
a. Consent for Internet-Based Services.A
! A A
A A
A
I I^N94R;4R
By using these features, you consent to the transmission of this information. !
not use the information to identify or contact you.
(
A
A ! <
A A '"7 A
Y Plug and Play and Plug and Play Extensions.6 A
6 A A A
A !
A
Y B( A !
A 8?
%6
Y ( ?S4:A *
A A
A
Y % 0 / % 0 /
6
Y B ! 0 ! ( B !
)B!0!-
B!0! B!0!<
! A
[ B!0! 0A
B
! A ( Z
B!0! ! B!0!
Z 6 B!0!
B A A
Y B ! 5 B B ! 5 !
Y A K
Y A K
Y A A
6 H I
I^1NS9**9.
Y ! # 0A I( &/ "
A
I^NO:4O*4)\! ]- AB A
! ! !
! '
6 [!
I^NO:4O*4
Y ' %
A A'# $5Z Z
(5I5 '# 6 A
query feature through a registry setting.
Y B # A A F
A A '5
Y # # # A 8? Z
# ? Z )^- %
) A -8A
# ? % Z )^-
A % 8 # ?
# ? % A !
A ! &5 A #
A I I^N*9R:* <
A [ A
6 ! %<
8? A
I I^N93O94;
Y ( / 8 I0A
I A A ! ( <
6 A
Y ! ( &5 ! (
< < A A
A
offers:
Y A
A
Y Z
Y A
Y 6 ! ( A A
collection and use of such information.
Y ! 5 / A
A !#(&05! 5 / A A
A
Y B / % A B / % )\B/%]-
A B / !#(&05
B / A A Z A
! B / A B /
A ) - B / A
Z
B
B / A!
( B /
A
b. Use of Information.! A !
A AB
A A !
c. Misuse of Internet-based Services.6 A
[ 6 A F
A
% %% ( '"7 0 A
A
) & *
'8 )\'8( ]-6
6 A
I I^1N;;R4;
' A !
! A
'8( A
I I^1N;;R4;
+ *%%/6 6
A
10. DOCUMENTATION.% A A
11. PROOF OF LICENSE. Z A
( %
A ? A '"7[
A A 6 A
A ! HII
.
& % /6 A (
% "
6
" '2 ## 3 #(# 3 % (
2# % (# $3;RI
%+(+(<9!587<R5 3 !587<3A
A !5871%11( Z H
$#50&/(#1(8'#8/'80&'8&0!&08+8&5%8'5&0&1&1(8'#8#
#/($%#%'B$&/1!%&'$8%+($8+(<9$8!587<R5%03+#/%1
%'$8!5873+8&5%8'5&0&1&1(8'#8#&0$8580#&'%1%''&'<
(&!!80(%1/#8&%(&'#/!80&)-8'(&8+8&'(&!51%'(8B$$8%"&+8
#%'%0#)\+8&#%'%0#]-%'I&0)-8(&8+8&$%B%#8'(&8"6%
(&'#/!808'7%78'%580#&'%1%''&'<(&!!80(%1%(+6&0B%#&"%'8
0&!%+8&50&+801(8'#8&50&+8+8&/'80#/($5%8'5&0&1&
1(8'#8#'&'8&$81(8'#8#8,8'&%'6&$8050&/(087%018##
&B$8$80#/($50&/(#'(1/8B$$#50&/('%#'718%0(18
'&1(8'#8#70%'8&0#$%11"8!518&0%'6&$80/#8%&'%1
'&0!%&'!%6"8&"%'80&!!5871%11(#88BBB!5871%(&!
2 %" !5*
#&I8(99923<* #&I8(9*O9O<*
A
$ & 5!6789:!;687<=886=:;8 ;!8==>85!6789:6;85
device and is responsible for how it operates on the device.
' ! Z <
6 ! A
A
& & 5!6789:!:6?>>@!!H/6<J:==:!K!
of using it. Microsoft gives no express warranties, guarantees or conditions. Any warranties
you receive regarding the device or the software do not originate from, and are not binding on,
:6!6786:8!7=8!5;==69>JQQ6<:=6==9!3 ;> :6!678V=<>X=>
9::;8!67X:5;8J=8Q38;!!76::8<=:<:6!;>;6;(;7:;ZX;8
) / /6<;:6?:7:6X :6!678;>8!7=8!6;=Q>:8>XZ!
<868965<;>:>78Q6==:![\$]]]^/6<;;68:6?:;Q685:>XZ!3
;=<>;Z6;!_<;8=3=6!8:68!3!=3;>:86:;>;8=>XZ!
This limitation applies to:
j ;Q85;Z:=8>8685!6789:3!:?!36;8;8[;=<>;Z6>^6;85:>:8Q;8:;8
sites, or third party programs, and
j =X!76:J:5676;8:83J:5679::;8Q3Z<:;86:6;>86;3!8:8=J=8Q3
negligence, or other tort to the extent permitted by applicable law.
It also applies even if Microsoft should have been aware of the possibility of the damages. The
above limitation may not apply to you because your country may not allow the exclusion or
limitation of incidental, consequential or other damages.
+ z% / # ? 6
?
I?
20. ENTIRE AGREEMENT. ) <
-
< A A
A
21. APPLICABLE LAW
a. United States. Z / # B A
j
AA
b. Outside the United States. Z
country apply.
22. Third Party Programs.! A
Z A
5 # # k1 " !
# # 1 ! Z
? H
( 9:O2# # 1
( 9:OO# # 1
( 9::4# # 1
5 # #
5 %(8M(&!!( " !
%(8M(&!!( ! Z ?
H
( 9::S<9::2%(8M(&!!(
5 # 1j #7 "
! # 1j #7 ! Z
? H
( v9:OO<9::2# 1j
( v9::9<9::2#7
5
A
)- A
)-
# 1j #7 A
# 1j #7
$8#&B%08#50&+8C%#<#C%'B$&/B%00%'6&%'6E'
8,508##!518&0&$80B#8'(1/'7B$&/1!%&'%'6
B%00%'6&!80($%'%"16&0'8##&0%5%0(/1%05/05
''&8+8'#$%11#%!18180&0#1(&'70%5$(#"81%"18&0
%'6#58(%1'(8'%1'08(&0(&'#8J/8'%1%!%78#&%'6E'
&0%'6%!%78#B$%#&8+8008#/1'70&!1&##&/#8%%&050&#
B$8$80&0'&%+#8&$85&##"16&%!%78%'&'%'6$8&06&
1%"16%0#'7&/&&0'(&''8(&'B$$8/#8&0580&0!%'(8
&$##&B%08
5 ( v9::O5 (
5 $ # " !
$ # ! Z ?
H
( v9::;<9:::$ #
B 2 <w5 ?
A HII <
F I HII <F I IFI I
5 ( v3444#0#1
VFV
5 # # " !
# # ! Z ?
H
? " k&(0v# #
5 /A # ( "
! /A # ( ! Z
? H
( v9::; /A # (
% A
5
A A
A
A
/A # ( # /A
A
$8/'+80#6&#&/$80'(%1&0'%
$##&B%08#50&+8C%##C%'B$&/%'68,508##
&0!518B%00%'8#'(1/'7B$&/1!%&'$8!518B%00%'8#&
!80($%'%"16%''8##&0%5%0(/1%05/05
&
5 T E F" !
T E F ! Z ?
H
(&5607$%'580!##&''&(8
% A
5
) C# C- #
I #
# A A )-
# A
)- 5 A
? ?C7"zC
)CC -
changed.
$8#&B%08#50&+8C%##CB$&/B%00%'6&%'6E'8,508##
&0!518'(1/'7"/'&1!8&$8B%00%'8#&!80($%'%"16
'8##&0%5%0(/1%05/05%''&''0'78!8'&$05%0607$#
''&8+8'#$%11$8(&5607$$&180&0$&180#'(1/8'$#'&(8"8
1%"18&0%'6(1%!&0%'6#58(%1'08(&0(&'#8J/8'%1%!%78#&0%'6
%!%78#B$%#&8+8008#/1'70&!1&##&/#8%%&050&#B$8$80'
%'%(&'&(&'0%('87178'(8&0&$80&0&/#%(&'%0#'7&/&&0
'(&''8(&'B$$8/#8&0580&0!%'(8&$##&B%08
8? A
# F
of the copyright holder.
(#%E!5# A
5 0#% # " !
0#% # ! Z
? H
( v9::40#% # % A
1 A C0#% #
!S! < % C
1 A A A
C A 0#% # !S! < % C
A
0#% #
AC C ?
I
5 &+" !
&+ ! Z
? H
( 9::*&+
5
A A
&+ A
&+
AC C ?
&58'+#&'#(1%!#%11B%00%'8#B$087%0&$##&B%08'(1/'7
%11!518B%00%'8#&!80($%'%"16%''8##''&8+8'#$%11
&58'+#&'"81%"18&0%'6#58(%1'08(&0(&'#8J/8'%1%!%78#&0%'6
%!%78#B$%#&8+8008#/1'70&!1&##&/#8%%&050&#B$8$80'
%'%(&'&(&'0%('87178'(8&0&$80&0&/#%(&'%0#'7&/&&0
'(&''8(&'B$$8/#8&0580&0!%'(8&$##&B%08
5 0 /A ! "
! 0 /A ! !
Z ? H
( v9::S9::;0 /A !
%0 0 A
5
A A
/A ! A
?
( v9::*9::R0 /A !
% A
0 A A
A /A ! %% /A
A
AVV VV ?
5 ! "
! ! !
Z ? H
( 9:O:9::4 ! %0 0 A
8? / # % Z /
# 7A F ?
such a license before exporting.
B$'$%(&'#0%'
A A
notice appear in all copies and that both that copyright notice and
!
A
!
AC C ?
/ /# ? /# /#
(
( 9::R ! %0 0 A
8? / # % Z /
# 7A F ?
such a license before exporting.
B$'$%(&'#0%'
A A
notice appear in all copies and that both that copyright notice and this permission notice appear in
! A
!
AC C ?
A /A ( "
5 C8 C
Northern Telecom.
5 $ <5 ( " !
$ <5 ( ! Z
? H
( v9::R$ <5 (
5
A A
$ <
5 ( ! (
AC C ?
VV5'7
5 % " !
% ! Z ?
H
v( 9::S%
K
T5877
\ + ] E#B A1
5 #7#<! "
! #7#<! !
Z ? H
( 9::;#7#<! %0 0 A
5 /" !
/ ! Z ?
H
(&5607$%'580!##&''&(8
( v9::9<344S/% A / HII
I
5 /
) C C- /
) C# C- #
I
# #
A ) - A )-
# )- A )-
v #
)- #
$8%%18#%'#&B%08%0850&+8C%##CB$&/B%00%'6&%'6
E'8,508##&0!518'(1/'7"/'&1!8&$8B%00%'8#&
!80($%'%"16'8##&0%5%0(/1%05/05%''&''0'78!8'
&$05%0607$#''&8+8'#$%11$8(&5607$$&180&0$&180#
'(1/8'$#'&(8"81%"18&0%'6(1%!&0%'6#58(%1'08(&0
(&'#8J/8'%1%!%78#&0%'6%!%78#B$%#&8+8008#/1'70&!1&##&
/#8%%&050&#B$8$80'%'%(&'&(&'0%('87178'(8&0&$80
&0&/#%(&'%0#'7&/&&0'(&''8(&'B$$8/#8&0580&0!%'(8
&$8%%18#&0#&B%08
8? A
#
F
(5 # A AA %#
! (
5 ! ( " !
! ( ! Z ?
H
$%1& 1 v9::9<9::3! (
5 1 0FF" !
1 0FF ! Z ?
H
v9::2<:O1 0FF) > -
5 A 5E ) > :Z -0 ! <w F ) >
- $ ) > -% 9::S
0 A
H
90 A
30 A
I A
$##&B%08#50&+8"6$8%/$&0#\%##VV%'%'68,508##&0
!518B%00%'8#'(1/'7"/'&1!8&$8!518B%00%'8#
&!80($%'%"16%''8##&0%5%0(/1%05/05%08#(1%!8
''&8+8'#$%11$8%/$&0#"81%"18&0%'608('08('(8'%1
#58(%18,8!51%06&0(&'#8J/8'%1%!%78#)'(1/'7"/'&1!8&
50&(/08!8'&#/"#/87&&#&0#80+(8#K1&##&/#8%%&050&#K
&0"/#'8##'800/5&'-$&B8+80(%/#8%'&'%'6$8&06&1%"16
B$8$80'(&'0%(#0(1%"16&0&0)'(1/'7'87178'(8&0
&$80B#8-%0#'7'%'6B%6&/&$8/#8&$##&B%088+8'%+#8
&$85&##"16&#/($%!%78
5 B*(" ! B*(
! Z ? H
B*(k#&B%08'&(8%'1(8'#8
HII * I( I1 I3443I < <344393*9
) 08%!8 -
A " I
) - A
and conditions.
5
A
%11 H
9 ? '&(8 A A A
3% <? ?
B*(# # ' ) ? ? -
A A
*' )B
A/01 A-
$##&B%08%'&(/!8'%&'#50&+8C%##C%'(&5607$$&180#
!%E8'&08508#8'%&'#&0B%00%'8#8,508##&0!518'(1/'7"/
'&1!8&B%00%'8#&!80($%'%"16&0'8##&0%'65%0(/1%0
5/05&0$%$8/#8&$8#&B%08&0&(/!8'%&'B11'&'0'78
%'6$05%065%8'#(&5607$#0%8!%0E#&0&$8007$#
(&5607$$&180#B11'&"81%"18&0%'608('08(#58(%1
&0(&'#8J/8'%1%!%78#%0#'7&/&%'6/#8&$8#&B%08&0
&(/!8'%&'
'& A
5 # ! " !
# ! ! Z
? H
# 05( # ! A A
/
# 05( F
? A
#/'05(#50&+8%##B$'&B%00%'8#&%'6E''(1/'7$8
B%00%'8#&8#7'!80($%'"16%''8##&0%5%0(/1%05/05&0
%0#'70&!%(&/0#8&8%1'7/#%78&00%850%((8
# 05( A # !
#/'!(0#8!#'(#$%11$%+8'&1%"16B$08#58(&$8'0'78!8'
&(&5607$#0%8#8(08#&0%'65%8'#"6#/'05(&0%'65%0$808&
A # ! A
Z A# A
# !
3SS47 %A
! + ( :R4R*
! 1 \] <
1 ( ( 9::3<9::21 %
A
5 % %? " !
% %? ! Z ?
H
The Loki Library
( v3449% %?
This code accompanies the book:
%? % C! (~~H7 5 5 %C
( v3449%<B
5
A A
notice and this permission notice appear in supporting documentation.
%<B1
AC C ?
5 ( v9::ST 0
5 !
)!-" ! ! !
Z ? H
( v3442 ! )!-% A
5 A C # (~~1 C( v9::S5T5
5 <$
5 $ <5 ( " !
$ <5 ( ! Z
? H
( v3443344*$ <5 (
% ' H
A HIIA
!5+!5+
A A
& # % ! !5+
HII IA
Permission Notice:
5
) C# C- #
I
# #
H
A A% '
#
$8#&B%08#50&+8C%##CB$&/B%00%'6&%'6E'8,508##&0
!518'(1/'7"/'&1!8&$8B%00%'8#&!80($%'%"16'8##
&0%5%0(/1%05/05%''&''0'78!8'''&8+8'#$%11$8%/$&0#
&0(&5607$$&180#"81%"18&0%'6(1%!%!%78#&0&$801%"16
B$8$80'%'%(&'&(&'0%(&0&0
&$80B#8%0#'70&!&/&&0'(&''8(&'B$$8#&B%08&0$8/#8
&0&$808%1'7#'$8#&B%08
8? A
# F
of the copyright holder.
% A