Professional Documents
Culture Documents
Dyi Rat
Dyi Rat
2. Identify the tonestack. Cut the tracks and install 4 wires after and before the cut. (I left the
3n3 capacitor to remove some high frequencies, but you can do the cut after this):
3. If you are going to install the bypass switch, drill the enclosure.
4. Solder the 4 wires to the DPDT bypass switch following the diagram:
5. Install the board again, screw the bypass switch and solder the in-out gyrator wires:
6. Remove the Rat supply wire (white) and the plastic cover. Solder both supply wires and
gnd.