Professional Documents
Culture Documents
Ucrete Pfs Tds
Ucrete Pfs Tds
Ucrete Pfs Tds
Heavy Duty Polyurethane Fast Slurry Primer For Ucrete Flooring Systems
CURING DISPOSAL
Prior to application of a subsequent coat, check that Part 2 containers should be decontaminated with 5%
the surface is hard and tack-free. The recoating time sodium carbonate (washing soda) solution after use
is de-pendent upon humidity and temperature, but and disposed of as building waste in accordance with
typically Ucrete PRIMER FS can be overlaid: local regulations.
after 7 hours at 5°C
after 4 hours at 10-15°C HEALTH AND SAFETY
after 3 hours at 20°C In its cured state Ucrete is physiologically non-
after 2 hours at 30°C hazardous.
Defects in the primed surface, such as blow holes in For normal flooring applications Ucrete does not
the surface as a result of air rising out of bleed run require the use of respiratory protective equipment
pores in the substrate, should be remedied prior to during installation.
overlaying, especially under Ucrete MF or Operatives should consult the CoSHH risk
Ucrete MFAS. Failure to do so may lead to surface assessment and their work instructions.
defects in the finished floor.
If the time between coats exceeds 30 hours, or if * Properties listed are based on laboratory controlled tests.
condensation or water impacts the surface, fully ® = Registered trademark of the MBCC Group in many countries.W
abrade the surface prior to overlaying.
CLEANING
Tools may be cleaned immediately after use using a
suitable thinner (Xylene / MEK / Acetone).
STORAGE
In covered warehouse conditions, above 5ºC and
below 30°C and out of direct sunlight. Materials must
MBS_CC-UAE/Ucr_PFS_08_13/v3/11_15/v4/05_20
The technical information and application advice given in this Master Builders Solutions publication are based on
STATEMENT OF the present state of our best scientific and practical knowledge. As the information herein is of a general nature, no
RESPONSIBILITY assumption can be made as to a product's suitability for a particular use or application and no warranty as to its
accuracy, reliability or completeness either expressed or implied is given other than those required by law. The user
is responsible for checking the suitability of products for their intended use.
Field service where provided does not constitute supervisory responsibility. Suggestions made by Master Builders
NOTE Solutions either orally or in writing may be followed, modified or rejected by the owner, engineer or contractor since
they, and not Master Builders Solutions, are responsible for carrying out procedures appropriate to a specific
application.