Professional Documents
Culture Documents
New Questions 1
New Questions 1
been lost?
3- you are going to trip out of the hole dry. 5” dp with a displacement of 0.008 bbl/foot and a capacity of
0.01776 bbl/ foot. Average stand length93’/stand. What is the volume to add to the well for 5 stands fill
up?
A. 12 bbls
B. 3.7 bbls
4- we are drilling with 9 ppg mud at 100 SPM, WOB is 25000, ad pump pressure is 3000 psi. If the driller
increases the pump speed to 120 SPM, what happens to ECD?
5-What do you calculate to keep enough pressure on the well when in a static? (non-circulating)
6- In killing a Horizontal well on bottom, you have to complete your kill sheet with which of the
following information?
A. True vertical depth, measured depth, end of build, kickoff point, mud wight, SIDPP, SICP, slow
pump rate, and shoe depth.
B. Measured depth, mud wight, SIDPP, SICP, pit gain
7- how ca you till the difference between drill gas and a kick?
9- the type of pill used for tripping safely in horizontal wells are called?
A. 156 bbls
B. 160 bbls
13- Why should pressure relief valves be installed in the MPD system?
14-with a rotating head and an orbit valve, what level of underbalance drilling can we safely accomplish?
A. Compensate for loss of ECD by closing orbit valve during connections to hold back pressure.
B. Managed pressure drilling, keeping bottom hole pressure nearly equal to formation pressure.
A. Height of pill = overbalance needed / (pill weight- MW) / 0.052, then, volume needed = height of
pill x hole capacity.
B. SCRP / MW / 0.052.
17- What is the purpose of the flame arrester in the flare stack (end of vent line on separator)?
A. To allow your vent line to light up the rig location hen circulating out a kick.
B. A passive device that allows gas to pass through it but stops the propagation on a flame.
18-How can you tell the how much pressure the rotating head is holding?
19-holding 1200psi at the surface will have the most effect on mud weight on which well
A. Indicates when casing shoe pressure should stop increasing while holding constant BHP.
B. Tells you that the casing shoe pressure will start increasing till gas is at choke.
A. They will prevent gas from flowing back into the mud gas separator.
B. Vent line check valve never be used.
26- A weighted pill is pumped into the well. As the pipe is pulled out of the pill, what will happen to
BHD?
A. To apply enough hydrostatic pressure to allow pipe to be pulled safely of the hole.
B. To keep enough volume to keep the well from flowing.
C. To cover the zone of interest.
D. All of the above.
28- What will happen to the as pipe is tripped out of the well?
A. The pill will always stay in the same place in the well as we trip out or in the hole.
B. The pill will move up in the well and will get shorter as pipe is pulled through it.
C. The pill will move up in the well and will get longer.
D. The pill will move down in the well and will get shorter as the pipe is pulled through it.
30- a rotating head used while MPD drilling give us the ability to safely accomplish what while drilling?
A. Allow lower mud weight to be used in the hole and less stress on the well.
B. Close the well in case of a kick
C. Keeping formation pressure over bottom hole pressure at all times.
D. All of the above.
32-if the RCD is leaking drilling fluid in hydrostatically overbalanced well, what is the first course of
action the driller should take?
A. 8.8 bbls
B. 6.6 bbls
C. 8.0 bbls
D. 2.2 bbls