Professional Documents
Culture Documents
TY - Elec Engg - Power Electronics - UNIT 5 - Lecture PPTs - Dr. R. T. Ugale
TY - Elec Engg - Power Electronics - UNIT 5 - Lecture PPTs - Dr. R. T. Ugale
Lecture :1
Course introduction, pre-requisite, Course Topics, Topic
wise Syllabus, Teaching/Lecture plan, Suggested
references, Teaching Scheme, Examination Scheme,
Course Outcomes
Course Instructor :
Dr. R. T. Ugale
Electrical Engg. Dept.
C.O.E. Pune-5
Principle of On-off and phase control Semi and full controlled SCR based
converters, Performance parameters and input-output waveforms for R, R-L, R-
E, R-L-E loads. Single phase AC voltage controllers with triacs, MOSFET based
PFC rectifier.
Thyristor based inverter: Single phase with R and R-L load. PWM Inverters:
single phase and three phase circuits, principle of operation, performance
parameters. Multilevel Inverters: Cascaded H bridge, diode clamp, (3 level).
Selected harmonic elimination PWM, Sinusoidal PWM (1ph and 3ph), third
harmonic injection, Space vector PWM. TTL & DSP logic for PWM generation
for power converters. PWM for Multilevel inverter.
Driver circuit design, Power loss and efficiency calculation for power
converters, Heat sink design and selection, Magnetic design for inductor and
transformer.
Reference Books:
• P. C. Sen, “Power Electronics”, Tata McGraw hill Publication
• Keith H. Sueker, "Power Electronic Design: A Practitioner’s Guide", Elsevier Publication.
• Kumar L. Ashok, “Power Electronics with MATLAB”, Cambridge University Press.
• B W Williams, “Power Electronics: Devices, Drivers, Applications and Passive Components”, Mac-millan
Publication.
• Issa Bataresh, Ahmad Harb, “Power Electronics circuit design & analysis”, second edition.
• “Power Electronics”, NPTEL video course by Prof. B. G. Fernandes, Kishore Chattarjee, IIT
Bombay, 2009. https://archive.nptel.ac.in/courses/108/101/108101038/
❖ Examination Scheme
Internal Tests/Quiz T1, T2 :20 Marks each
UNIT 5
Lecture 24:
DC-DC Converters / Choppers
Course Instructor :
Dr. R. T. Ugale
Electrical Engg. Dept.
C.O.E. Pune-5
Chopper: Part I
Chopper: Part II
Class B Chopper
Class C Chopper
UNIT 5
Lecture 27:
Switch Mode Power Supply (SMPS)
Course Instructor :
Dr. R. T. Ugale
Electrical Engg. Dept.
C.O.E. Pune-5