Professional Documents
Culture Documents
ATLAS FB 251 Versione 2 Ing
ATLAS FB 251 Versione 2 Ing
FB 251
UPDATED 31/05/2012
to new modifications
Massimo Santini
+39 348 809 0102
TABLES OF CONTENTS
INTRODUCTION 1
ELECTRIC PUMPS FOR WHIRPOOL – MODEL PC 3HP T 2
FILTER ELECTRIC PUMP – MODEL PC0,75HP T 3
THERMOSTAT – CODEC 233000070 4
BLOWER – CODEC SCL K-MS MOR 5
FILTER UNIT – CODEC BF55 STDF 1GS 14
SWIMMING FILLING 15
SWIMMING FRESH WATER DISCHARGE 16
WHIRLPOOL SYSTEM 17
LIGHT – CODEC 442231420 17
PURFIER NATURE 2 EXPRESS 19
ELECTRIC SYSTEM SINGLE WIRE DIAGRAMS 23
FB 251 1
INTRODUCTION
The Jacuzzi installed onboard your yacht is composed of the following components:
SET setting
Access the “Machine Status” menu by pressing and quickly releasing the “SET” key.
The Label of the “SET” folder appears. To display the SET point value press “SET”
key again. The value appears on the display.
To change the SET point value, use the “UP” and “DOWN” keys within 15 seconds.
If the parameter is LOC = y the SET point cannot be changed.
Display probes
By pressing the “SET” key when the appropriate Label appears, the value of the probe
associated to it is displayed.
Programmino menu
To enter the “programmino” menu, press the “SET” key for more than 5 seconds. If
specified, the access PASSWORD will be requested, (parameter “PA1”), and (if the
password is correct) the label of the first folder will follow.
To scroll through the other folders, use the “UP” and “DOWN” keys; the folders contain
the level 1 parameters. If the password is wrong, the display will show the PA1 label
again. To enter the folder, press “SET”. The label of the first visible parameter, press
and release “SET”, then set the desired value using “UP” and “DOWN” keys, and
confirm with the “SET” key to move to the next parameter.
Passowrd
The Password “PA1” allow access to level 1 parameters. In the standard configuration
passwords are not present.
To enable them (value 0) and assign them the desired value, access the
“Programming” menu (see the “Programming Menu” section).
FB 251 5
Cartdridge 1
High 49,50
Dimension 33 x 33
Weight 12 Kg
FB 251 15
SWIMMING FILLING
The swimming pool is filled automatically. The main switchboard is provided with two
pushbuttons for allowing filling with cold fresh water or hot fresh water, coming directly
from the yacht's circuit.
It is possible to press one of the two pushbuttons, or both pushbuttons simultaneously.
Special solenoid valves 1’ ¼ allow water admission in the swimming pool, which can
contain approximately 4,8 m3 of water.
The fresh water flows through two solenoid valves, one for hot water and one for cold
water.
Once filled the swimming pool, the water shall overflow into the compensation tank,
provided with 3 level sensors:
1 – safety level
2 – pool minimum filling level
3 – pool maximum filling level
The two heaters, installed downstream of the filtration pump and controlled by the
special thermal switch, control the water temperature inside the swimming pool.
When water reach the maximum level in the tank , the filling stops and the filtering pump starts.
When you start the filling , if the tank is full , the filtering pump starts immidiately just to pour the
water located into the tank , in the pool. Then you can decide whether to reuse that water and
continue filling that continues automatically , or drain it and restart filling with fresh water in the pool.
At the end of the filling the solenoid valves will be closed, but lights in push-buttons still on,
showing that the automatic reffillig still active. If this is not desired push the filling buttons again,
to disactivate the automatic refilling.
The two 3 Hp electric pumps withdraw the water from four openings located on the
pool's bottom and send it again to the pool through the 18 Jacuzzi nozzles. When the
water flows through the Jacuzzi nozzle, due to the Venturi effect, air is sucked and
mixed with water, producing the Jacuzzi effect.
A special fan sucks the air from outside and sends it into the pool through the 20
nozzles.
1 – Jacuzzi nozzles
2 – air admission nozzles
3 – electric pumps HYDRO 1 / HYDRO 2
4 – air suction
5 – fan
FB 251 23