Professional Documents
Culture Documents
Data Monitor or Logger & Parameters 29 Nop 2017
Data Monitor or Logger & Parameters 29 Nop 2017
Minimum Maximum
Parameter Value Units
Measured Measured
HHHHHH: 001853:43: 001853:43:
ECM Time (Key On Time) 001853:52:15
MM:SS 38 38
Engine Distance 12515.1 mi 12515.1 12515.1
Engine Brake Output Circuit 1 Inactive
Engine Brake Output Circuit 2 Inactive
Engine Brake Output Circuit 3 Inactive
Engine Brake Output Circuit 4 Inactive
Engine Brake Selector Switch 1 On
Engine Brake Selector Switch 2 Off
Engine Brake Switch Level 33 percent 33 33
Engine Coolant Level Normal
Engine Coolant Temperature 155.5 °F 138.4 155.5
Engine Coolant Temperature Sensor Signal Voltage 1.19 V 1.19 1.56
HHHHHH: 001809:13: 001809:13:
Engine Hours 001809:22:07
MM:SS 31 31
Engine Oil Pressure 33.1 psi 33.1 37.1
Engine Oil Pressure Sensor Signal Voltage 2.13 V 2.13 2.38
Engine Oil Pressure Sensor Type Analog
Engine Oil Temperature 156.6 °F 138.3 156.6
Engine Oil Temperature Sensor Signal Voltage 1.19 V 1.19 1.56
Low Speed Governor
Engine Operating State
State
Engine Protection Derate Suppress Disable
Engine Protection Shutdown Override Switch Off
Engine Speed 800 RPM 798 1022
Engine Speed Backup Sensor State Valid Signal
Engine Speed Backup Synchronization State Have Synchronization
Engine Speed Main Sensor Signal State In Range
Engine Speed Main Sensor State Valid Signal
Engine Speed Main Synchronization State Have Synchronization
Engine Speed Sensor Active Main
Engine Speed Status Good
Engine Torque Mode Low Idle Governor
Engine Warmup Protection Status Inactive
Exhaust Gas Pressure 44.07 InHg 43.10 52.75
Exhaust Gas Pressure Sensor Signal Voltage 1.19 V 1.19 1.56
Exhaust Gas Temperature (Calculated) 289 °F 270 330
Exhaust Mass Flowrate 15.2 lb/min 14.7 18.1
Fan Control 2 Multiplexed Request Level 0.0 percent 0.0 0.0
Fan Control Command 0 percent 0 0
Fan Control Multiplexed Request Level 0 percent 0 0
Fan Control Switch On
Fan Drive State Manual Switch or Datalink
Fuel Flow Rate Commanded 8.91 gph 0.00 20.28
Fuel Pump Actuator Commanded Current 1.44 mA 1.25 2.19
Minimum Maximum
Parameter Value Units
Measured Measured
Fuel Pump Actuator Duty Cycle 40 percent 32 49
Fuel Pump Actuator Measured Current 1.69 mA 1.31 2.19
Fuel Pump Actuator Position Close
Fuel Rail Pressure Commanded 7575 psi 7256 13911
Fuel Rail Pressure Measured 7538 psi 6965 13057
Fuel Rail Pressure Sensor Signal Voltage 1.24 V 1.17 1.74
Idle Validation Switch Idle
Instantaneous Fuel Economy 0.0 mpg 0.0 0.0
Intake Manifold Air Temperature 94.8 °F 94.8 102.8
Intake Manifold Air Temperature Sensor Signal Voltage 1.00 V 0.81 1.00
Intake Manifold Pressure 6.0 InHg 5.0 8.3
Intake Manifold Pressure Sensor Signal Voltage 1.13 V 1.06 1.19
J1939 Engine Source Address 0 0 0
J1939 Stop Broadcast Source Address One 0 0 0
J1939 Stop Broadcast Source Address Three 0 0 0
J1939 Stop Broadcast Source Address Two 0 0 0
Keyswitch On
Keyswitch Off Counts 354 354 354
Keyswitch On Counts 355 355 355
Load Based Speed Control Status Not Limiting
Low Idle Adjustment Switch Neutral
OEM Ambient Air Temperature 85 °F 85 85
OEM Ambient Air Temperature Sensor Signal Voltage 2.94 V 2.94 2.94
Percent Accelerator Pedal or Lever 0 percent 0 55
Percent Load 3 percent 0 21
Percent Remote Accelerator Pedal or Lever 0 percent 0 0
Red Stop Lamp Status Off
Remote Accelerator Pedal or Lever Switch Off
Remote Accelerator Position Sensor Voltage 0.8 V 0.8 0.8
Sensor Supply 1 5.00 V 5.00 5.00
Sensor Supply 2 5.00 V 5.00 5.00
Sensor Supply 3 5.00 V 5.00 5.00
Sensor Supply 4 5.00 V 5.00 5.00
Sensor Supply 5 5.00 V 5.00 5.00
Sensor Supply 6 5.00 V 5.00 5.00
Starter Lockout Relay Command Open
Transmission Gear Ratio 16.00 16.00 16.00
Turbocharger Actuator Position Commanded (Percent 71 percent 58 71
Turbocharger Actuator Position Measured (Percent Closed) 71 percent 64 71
Turbocharger Actuator Position Sensor Signal Voltage 0.00 V 0.00 0.00
Turbocharger Actuator Type Electric
Turbocharger Compressor Intake Air Temperature 86.6 °F 86.6 100.7
Turbocharger Compressor Intake Air Temperature Sensor
2.69 V 2.63 2.69
Signal Voltage
Minimum Maximum
Parameter Value Units
Measured Measured
Turbocharger Speed 39000 RPM 37438 45602
Turbocharger Speed Derate Active Inactive
Vehicle Speed 0 mph 0 0
HHHHHH: 000000:00: 000000:00:
Water In Fuel Detected Total Accumulated Time 000000:00:00
MM:SS 00 00
Water in Fuel Sensor Signal Voltage 4.0 V 4.0 4.1
Water In Fuel State No Water Detected