Professional Documents
Culture Documents
Gravograph LS100 LS100Ex Lasering Parameters
Gravograph LS100 LS100Ex Lasering Parameters
This document provides a base of engraving parameters to be used on Gravograph laserable materials. They are indicative values that can be subject to modification, that are
recommended by professional engravers and that have been tested and verified for LS100Ex & LS100 35W
The goal of this document is to help each engraver get a first idea as to how to engrave on Gravograph laserable materials.
The parameters are present in grids and are sorted by product range. Every material can have up to 3 different types of engraving:
- Vector, for lightweight linear tracing
- Raster, for heavy marking
- Cutting
Some materials may not be engraved with a certain type of engraving: if the specific type is not present in the grid of the material, then it's most likely that it is not a
recommended engraving method to use on the material.
Best Practices
Floating Pin Table Cutting - When using a floating pin table, place an aluminium plate under the strips to avoid laser reflection to prevent engraving under the
material.
Gravogrip Raster - Use Gravogrip when engraving on thin materials as they can have uneven surfaces.
Raster - Avoid using too much power when engraving to prevent damage to the Gravogrip plate.
In case there is an unexpected behavior during the engraving, please refer to the machine's User Manual for help and advice on how to handle such matters.
Gravograph LS100Ex & LS100 35W Lasering Parameters
Reminder The lasering parameters provided in this document are a reference for quality engraving.
ACRYLIC
ALUMAMARK
COLORED ALUMINUM
FLEXILASE
GRAVOGLAS 1
GRAVOLASE METALLICS
GRAVOMETALL MATTE
GRAVOPLY 2
GRAVOPLY LASER
GRAVOPLY ULTRA
GRAVOSTRAT
GRAVOTAC EXTERIOR
GRAVOXAL MATTE
METALLEX INDOOR
RUBBALASE
STICKALASE
TROPHY BRASS