Professional Documents
Culture Documents
Diagnostics Quick Start Guide 121222
Diagnostics Quick Start Guide 121222
G E T TO K N OW YO U R VC I D E V I C E
FRONT of VCI TOP of VCI BACK of VCI TM
1 2 Power 7 8
1
3 Ready
4 Vehicle Data
5 Connected
1. Insert the serial connector 1. Open your Bluetooth 5. Open ALLDATA 1. Tap the VCI device you
into the VCI hardware. settings within your application. want to connect to.
Android or Windows
2. Insert the OBD connector device. 6. After successfully 2. To auto populate
into the vehicle’s pairing to the VCI, supported scan
diagnostic port. 2. Find the select the Diagnostics options, move Power
device named tile on the welcome the toggle for the Ready
3. Turn vehicle’s ignition to ALLDATA-OBD page and then click on Manual Selection at Vehicle Data
“on” position (make sure your the Settings option.
the bottom of the Connected
device is fully
page to OFF. (It will Error
4. During the boot process, booted and ready). 7. In Settings, specify the
all five light indicators Default Device in OBDII
be ON by default.)
will illuminate. 3. Select device and, Device Management.
Power
when prompted, enter Move the Default 3. The orange
5. After initial boot, only the
Ready
1234 as the Host Key. Device slider to “on” to Connected light on
Power and Vehicle Data
Vehicle Data
auto-connect your VCI. the VCI will illuminate
indicators will illuminate.
Connected
4. After pairing, when the connection
Error
ALLDATA-OBD will Keep the slider “off” is successful.
6. When only the Power Power
be listed within the to always manually
and Ready indicators are Ready
Paired Devices list. select the VCI from 4. Complete each step.
illuminated, the device Vehicle Data
the Devices list. Finish by choosing
is ready to use. NOTE: Pairing is not required
Connected for iOS devices. The VCI will
the Scan Range &
automatically populate in the 8. Exit Settings to return DTC type and press
Error
list of available devices. to the main page. NEXT.