Corollaaxio 201004 Part1 Part2

You might also like

Download as pdf or txt
Download as pdf or txt
You are on page 1of 26

Machine Translated by Google

Make sure to touch the sensor on the


back of the handle. 1

It cannot be unlocked for 3 seconds after the locking operation.

Door unlocking / locking (front door handle only)

Grasp
1-2. How to openthe handle
and close to /unlock
the door trunk, how to lock Before driving

Press the lock switch to lock

Unlocking the trunk

Press and hold the trunk open


switch to unlock

twenty one
Machine Translated by Google
1-2. How to open and close the door / trunk, how to lock

Antenna position and operating range

ÿ Antenna position

External antenna

In-car antenna

Antenna in the trunk

Antenna outside the trunk

ÿ Operating range (electronic key detection area)

: When locking / unlocking the door

It works when you carry an


electronic key within about 70
cm of the front door handle.
(Only the door handle that
detects the electronic key works)

: Unlocking the trunk

It works when you carry an electronic


key within a circumference of about 70
cm from the trunk open switch.

: When starting the engine or switching

modes

It works when you carry an


electronic key in the car.

twenty two
Machine Translated by Google

knowledge

ÿ Operation signal
1-2. How to open and close the door / trunk, how to lock Before driving
You will be notified by a buzzer and a blinking emergency flashing light. (Locking once, unlocking twice)

ÿ Power saving function

To protect the electronic key battery and vehicle battery, the smart entry & start system will be shut
down in the following situations:

• Did not use the smart entry & start system for more than 2 weeks

• The electronic key was left for 10 minutes or more within about 1 m outside the vehicle.

Do one of the following to restore the smart entry and start system.

• Lock with the lock switch on the door handle

• Lock / unlock with wireless function (oP. 29)

• Lock and unlock with a mechanical key (oP. 269)

ÿ About battery consumption

• The standard battery life is 1-2 years (the battery will be consumed without using the electronic
key). If the smart entry and start system or wireless function does not work or the operating range
is narrowed, the battery may be exhausted. If the battery becomes weak, replace it with a new

one. (OP. 223)

• When the battery level is low, a warning sound will sound from inside the vehicle when the engine is stopped.

vinegar. (OP. 254)

• 1 m of electrical appliances that generate magnetism as shown below to prevent significant battery consumption

Do not put the electronic key within.

ÿ TV

ÿ PC ÿ twenty three

Charging mobile phone or cordless phone ÿ Desk


lamp
Machine Translated by Google
1-2. How to open and close the door / trunk, how to lock

ÿ To operate the system correctly

Be sure to carry the electronic key with you before operating it. Also, when operating from outside the vehicle,

do not bring the electronic key too close to the vehicle. Depending on the position and holding of the electronic

key during operation, the electronic key may not be detected correctly and the system may not operate

correctly. (The alarm may sound by mistake, or the key lock prevention function may not work.)

ÿ Things to keep in mind

• Even if the electronic key is within the operating range (within the detection area), it is correct in the following cases.

It may not work properly.

ÿ When locking / unlocking the door, the electronic key gets too close to the door glass or door handle.

Or if it is near the ground or in a high place

-When the electronic key is near the ground or high, or too close to the center of the rear bumper when

unlocking the trunk.-When starting the engine or switching modes, the electronic key is on the

instrument panel, on the floor, or in the package tray behind the rear seat. If it was placed on top or in a

glove box, etc.

• If the electronic key is within the operating range, it can be locked by anyone other than the person carrying the electronic key.

It can be unlocked.

• The engine can be started when the electronic key is located near the door glass even outside the vehicle.

It may be possible.

• If the door handle is exposed to a large amount of water due to car washing or heavy rain, the door may be

unlocked. (If there is no door opening / closing operation, it will be locked automatically after about 30

seconds.)

• If you are wearing gloves, it may not be unlocked even if you hold the door handle.

vinegar.

• If you lock the electronic key near the vehicle with the wireless function, you may not be able to unlock it

with the smart entry & start system. (Recovers when unlocked using the wireless function)

twenty four
Machine Translated by Google

ÿ When not driving for a long time

Keep the electronic key at least 2 m away from the vehicle to prevent theft.

ÿ Security function for unlocking operation 1-2. How to open and close the door / trunk, how to lock Before driving

If the door cannot be opened within about 30 seconds after the unlocking operation, it will be locked to prevent

theft.

ÿ About warning sound and warning display

To prevent unexpected accidents and theft due to erroneous operation, warning sounds may be heard, warning

lights may be turned on, or warnings may be displayed on the multi-information display inside or outside the

vehicle.

• When the warning light comes on

Take appropriate action according to the situation. (OP. 241)

• When a warning is displayed on the multi-information display

(Vehicles equipped with Optitron meter) Take

appropriate measures based on the display. (OP. 246)

twenty five
Machine Translated by Google
1-2. How to open and close the door / trunk, how to lock

The situation and remedy when only the warning sound sounds are as follows.

alarm Status Workaround

I tried to lock the door with the


After removing the electronic key
smart entry & start system while I
from the car, lock it again.
left the electronic key in the car
when.


“I tried to lock the door by Turn off the "engine start stop"
"Pee" from outside
taking the engine key out switch and then lock it again.
the car for 2 seconds
without turning off the engine
start / stop switch. stomach.

The trunk was closed with After removing the electronic key

the electronic key in the from the trunk, close the trunk.

trunk with all doors locked.


Attempted to lock with the Smart

"Pee" from outside Entrey & Start system when one of Close all doors and then lock again.

the car for 10 seconds the doors is open

One beep from inside The battery of the electronic key is Replace it with a new battery. (OP.

the car low 223)

I tried to open the door and go


Keeps beeping from Set the shift lever to P.
outside with the shift lever in a
inside the car *
position other than P.

With the driver's door open, the

"engine start / stop" switch was set After turning off the "engine start

to accession mode (the transfer stop" switch, close the driver's door.

It keeps beeping from door was opened when in accession

inside the car mode).

The driver's door is open


Please close the driver's door
and turn off the "engine start stop" switch.
stomach.

* : Automatic car

26
Machine Translated by Google

ÿ When the smart entry & start system does not work properly

• Door unlocking and locking: oP. 269

• Engine start: oP. 269

ÿ When the battery runs out


1
oP. 223

ÿ Functions that can be set at the store

You can make changes such as deactivating the smart entry & start system. (Customization
list: oP. 290) 1-2. How to open and close the door / trunk, how to lock Before driving

caveat

ÿ Warning about the effects of radio waves

• If you have an implantable cardiac pacemaker or an implantable cardioverter-defibrillator,


keep it within about 22 cm from the indoor antenna / outside antenna (oP. 22). Radio waves
can affect the operation of implantable cardiac pacemakers and implantable cardioverter-
defibrillators.

• When using medical electrical equipment other than implantable cardiac pacemakers and
implantable cardioverter-defibrillators, check with the medical electrical equipment
manufacturer in advance about the effects of radio waves. Radio waves may affect the
operation of medical electrical equipment.

You can also deactivate the smart entry and start system. Please contact your Toyota dealer for
details.

27
Machine Translated by Google
1-2. How to open and close the door / trunk, how to lock

caution

ÿ Situations where the function may not work properly

The smart entry & start system uses weak radio waves. In the following cases, communication between the

electronic key and the vehicle may be interrupted, and the smart entry & start system or wireless remote control

may not operate normally. (Countermeasure method: oP. 269)

• When the battery of the electronic key is exhausted

• When you are in a place that generates strong radio waves or noise, such as a TV tower, power plant, gas

station, broadcasting station, large display, or air port nearby.

• When carrying a wireless communication device such as a wireless device, mobile phone, or cordless phone

• When the electronic key is in contact with or covered with a metal object

• When multiple electronic keys are nearby

• Carrying or using an electronic key at the same time as a product that emits the following radio waves
When

• Electronic keys of other cars

• Radio-controlled wireless remote

control • PC

• When a film containing metal is attached to the rear glass

28 28
Machine Translated by Google
1-2. How to open and close the door / trunk, how to lock
the wireless remote controller

The door can be locked and unlocked.

Vehicles equipped with smart entry & start system

All doors locked

All doors unlocked 1

Trunk unlock (long press)

Before driving

Vehicles without smart entry & start system All doors locked All doors

unlocked

29
Machine Translated by Google
1-2. How to open and close the door / trunk, how to lock

knowledge

ÿ Operation signal

Door: Buzzer (vehicle with smart entry & start system) and emergency points

You will be notified by blinking the extinguishing light. (Locking once, unlocking twice)

Trunk: A buzzer will notify you.

ÿ Half-door warning buzzer (vehicles equipped with smart entry & start system)

If you try to lock the door when it is not completely closed, the buzzer will sound. Close the door

completely and then lock it again.

ÿ About battery consumption

oP. 23

ÿ Security function for unlocking operation

oP. 25

ÿ When the battery runs out

oP. 223

ÿ Situations where the function may not work properly (Smart Entry & Start Sys)
Tem-equipped vehicle)

oP. 28

ÿ Functions that can be set at the store

You can make changes such as deactivating the wireless remote control.

(Customization list: oP. 290)

30
Machine Translated by Google

caution

ÿ Situations where the function may not work properly (Smart Entry & Start Sys)

Vehicles without a system)

In the following cases, the wireless function may not work properly.

• If there are facilities that generate strong radio waves, such as TV towers, power plants, broadcasting stations, and airports,

tree

• When carrying a wireless communication device such as a wireless device, mobile phone, or cordless phone

• When multiple wireless keys are nearby

• When the wireless key is in contact with or covered with metal objects

• When using a radio wave wireless key nearby

• When the wireless key is placed near an electric appliance such as a personal computer
Machine Translated by Google
1-2. How to open and close the door / trunk, how to lock
the door

It can be locked and unlocked using the smart entry & start system, wireless
function, key, and door lock switch.

ÿ Smart entry & start system


(Vehicles equipped with smart entry & start system) oP. 20

ÿ Wireless function
oP. 29

ÿ
Vehicles equipped with the key smart entry & start
system You can lock and unlock the door using the mechanical key. (OP. 269)
Vehicles without smart entry & start system
All doors locked

All doors unlocked

ÿ Door lock switch


All doors locked

All doors unlocked

32
Machine Translated by Google

The driver's door can be opened by 1


ÿ Lock lever pulling the door lever inside the car,
even if the lock lever is on the lock side.
Locking

and unlocking

1-2. How to open and close the door / trunk, how to lock Before driving

When locking the front seat from the outside without using the key

Step 1 Set the lock lever to the lock side


Step 2 Close the door while pulling the door handle

Vehicles equipped
Depending withofsmart
on the position entry &key,
the electronic start
the system
key may not be detected correctly and may be
locked.
The "engine start / stop" switch is not locked when it is in accessory mode or ignition
ON mode, or when the electronic key is left in the car.

Vehicles without smart entry & start system

It is not locked when the key is plugged into the engine switch.

33 33
Machine Translated by Google
1-2. How to open and close the door / trunk, how to lock

Child protector

When set to the locked side, the rear seat


door will not open from the inside.

You can prevent your child from opening the


rear door from the inside. Set the rear seat

doors on both sides to the locked side.

knowledge

ÿ How to open the door when using the child protector

Unlock the door and pull the door handle outside the car to open it. If you should open it
from inside the car, lower the door glass, reach out, and pull the door handle outside the car.

caveat

ÿ To prevent accidents

Be sure to observe the following while driving. If


not followed, the door may open unexpectedly, resulting in serious injury or, in the worst
case, death.

• Be sure to use a seat belt

• Lock all doors

• Securely close all doors

• Do not pull the door handle inside the door while driving
Doors can open and be thrown out of the car, resulting in serious injury or, in the worst
case, death. In particular, be careful because the door of the driver's seat will open even
if the lock lever is on the locked side.

• When you put your child in the rear seat, use a child protector to get inside the car.
Prevent the door from opening

34
Machine Translated by Google
1-2. How to open and close the door / trunk, how to
lock the trunk

Trunk opener, smart entry & start system, key


You can use it to open it.

ÿ How to open the trunk from inside the car


Pull the lever to unlock the trunk 1

Before driving

ÿ How to open the trunk from outside the car


Smart entry & start system (vehicles with
smart entry & start system) oP. 20 key (vehicles
without smart entry & start system)

Turn the key to unlock the trunk

35
Machine Translated by Google
1-2. How to open and close the door / trunk, how to lock

knowledge

ÿ Luggage room light

When you open the boot, the luggage room light


will light up.

ÿ About the key lock-in prevention function in the trunk


(Vehicles equipped with smart entry & start system)

If you close the trunk with the electronic key in the trunk, you will hear a beep. At this time, you
can open the trunk by pressing the trunk open switch.

caveat

ÿ Warning while driving

• Close the trunk while driving.


If you drive with the trunk open, the trunk may hit something outside the vehicle or your
luggage may be thrown out, which may lead to an unexpected accident, which is dangerous.
In addition, exhaust gas may enter the vehicle and cause serious health problems or death,
which is dangerous. Make sure the trunk is closed before riding
stomach.

• Make sure the trunk is completely closed before riding. If the trunk is not completely closed, the
trunk may suddenly open while driving, which may lead to an unexpected accident, which is
dangerous.

• Never put people in the trunk. It is dangerous because it may cause serious injury or even death
in the worst case when you make a sudden brake, make a sharp turn or collide.

36
Machine Translated by Google

1
caveat

ÿ When carrying a child

Please be sure to observe the following.


1-2. How to open and close the door / trunk, how to lock Before driving
If not followed, it can be dangerous as it can lead to serious injury or even death in the worst
case.

• Do not let your child play in the trunk.


If you are accidentally trapped, it may cause heat stroke or suffocation.

• Do not allow children to open or close the trunk.


The boot lid may operate unexpectedly or you may pinch your hands, head, neck, etc.
when closing it.

ÿ When using the trunk

Please be sure to observe the following.


If you do not observe it, it is dangerous because it may cause serious injury such as pinching
your body.

• Before opening the boot, remove heavy objects such as snow and ice on the boot lid. The
weight may cause the boot lid to fall after opening.

• When opening and closing the trunk, make sure that the surrounding area is safe.

• When there are people, please make a "call" to confirm safety and inform them that they will move.
stomach.

• Be careful when opening and closing in strong


winds. The boot lid may be blown by the wind and open and close vigorously.

37 37
Machine Translated by Google
1-2. How to open and close the door / trunk, how to lock

caveat

• If used in the half-open state, the boot lid


may fall and cause serious injury.
Especially on slopes, it is more difficult to
open and close the trunk than on a flat
surface, which can cause the trunk to
open and close suddenly. Be sure to
check that the trunk is fully open and
stationary before using it.
• When closing the trunk, be careful not to
get your fingers caught in the trunk.

• Be sure to lightly press the upper surface of the


boot lid from the outside to close the boot.

• Do not attach accessories other than genuine Toyota products to the boot lid. If
the boot lid is heavy, it may fall off after opening.

38
Machine Translated by Google
1-3. How to adjust the seat, handle
and mirror Front seat

Front-back position

adjustment Reclining adjustment

Vertical adjustment of the entire seat *

Before driving

caveat

ÿ About reclining adjustment

• Do not tilt the backrest more than necessary.


In the event of an accident, your body may slip under your seatbelt, causing serious life-
threatening injuries such as strong pressure on your abdomen, which is dangerous.

• After adjusting the seat, make sure that the seat is properly fixed.

* : Different equipment and optional equipment depending on the vehicle model, etc.

39 39
Machine Translated by Google
1-3. How to adjust the seat, handle and
mirror Rear seat

Lower the headrest all the


way down. Pull up the rear
seat forward knob to unlock
it and tilt the backrest. When
returning it, raise the backrest
and fix it. *

caveat

ÿ When moving the backrest forward

Please be sure to observe the following.


Failure to observe can result in serious injury or, in the worst case, death.

• Do not move forward while driving

• Make sure to apply the parking brake on a flat surface and set the shift lever to P.

• Do not drive with people on the backrest or trunk

• Be careful not to let your child enter the trunk

* : Different equipment and optional equipment depending on the vehicle model, etc.

40
Machine Translated by Google

1
caveat

ÿ After returning the backrest to its original position

Please be sure to observe the following.


1-3.worst
Failure to observe can result in serious injury or, in the How to adjustdeath.
case, the seat, steering wheel and mirror Before driving

• Shake the sheet back and forth lightly to ensure firmness.


If the
seat to be fixed is not securely fastened, you will
see red at the bottom of the knob. Make sure you
don't see the red color.

• Do not pinch the seat belt. The seat belt is damaged


There is a record.

41 41
Machine Translated by Google
1-3. How to adjust the seat, handle and
mirror Headrest

Vertical adjustment

To lower it, hold down the release button.

Remove

Remove while pressing the release button


To do.
Release button

knowledge

ÿ About the rear center seat *

When using it, always make it one step higher than the storage position.

ÿ About the height of the headrest


Be sure to adjust so that the center of the
headrest is near the top of both ears.

caveat

ÿ About the headrest

Please observe the following.


Failure to observe can result in serious injury or, in the worst case, death.

• Use headrests exclusively for each seat.

• Adjust the headrest to the correct position

• Do not drive with the headrest removed

* : Different equipment and optional equipment depending on the vehicle model, etc.

42
Machine Translated by Google
1-3. How to adjust the seat, handle and
mirror Seat belt

All occupants must wear seat belts properly before riding


stomach.

ÿ To wear properly 3-
point seat belt 1

• Put the shoulder belt on your shoulders

Do not hang it on your neck or


Before driving

remove it from your shoulders.

• Make sure that the waist belt is in close


contact with the hip bone as low as possible.

• Adjust the backrest, raise your


upper body, and sit deeply.
• Avoid twisting
Two-point seat belt

• Make sure that the waist belt is in close


contact with the hip bone as low as possible.

• Adjust the backrest, raise your


upper body, and sit deeply.
• Avoid twisting

43
Machine Translated by Google
1-3. How to adjust the seat, handle and mirror

ÿ How to put on and take off

Fixed

Insert it until you hear a click.

lift
Press the release button.

Release button

ÿ Adjust the height of the seat belt (front seat) Lower and

raise

When it clicks and is fixed, move it


to the point.

ÿ Adjusting the length of the seat belt (2-point seat belt) Extend

Shrink

44
Machine Translated by Google

1
It may not operate when the impact from
the front is weak or when the impact is
Seatbelt pretensioner (front seat)
from the side or the back.

When a to
1-3. How strong collision
adjust the is received
seat, steering from
wheel and mirror Before driving
the front, the seat belt is pulled in to ensure
an appropriate occupant restraint effect.

It works the same when you apply a sudden brake or when the car loses control.
(OP. 146)
Pre-crash seat belt (front seat of car with pre-crash safety)
When a collision object is detected by the pre-crash sensor and it is determined
that a collision is unavoidable, the front seat belt is caught before the collision to
enhance the effect of the pretensioner.

45 45
Machine Translated by Google
1-3. How to adjust the seat, handle and mirror

knowledge

ÿ Emergency seatbelt fixing mechanism

The belt locks when there is a sudden stop or impact. It may lock even if you suddenly lean forward
or pull out the seat belt quickly. You can pull out the belt by pulling it hard, loosening it, and moving it
slowly.

ÿ For pregnant women and those with illness

Check with your doctor for precautions and be sure to


wear it correctly. (OP. 43) If you are pregnant, wear it
under the bulge of your abdomen so that the waist belt
rests as low as possible on your hip bone, just as you
would normally wear it. Also, make sure that the
shoulder belt passes through your shoulders, avoiding
the bulge of your abdomen, and wear it so that it rests
on your chest. If the belt is not worn properly, not only
the mother but also the fetus may be seriously injured
in the event of a collision, and in the worst case, death
may occur.

46

You might also like