Professional Documents
Culture Documents
Card Reader
Card Reader
Reader Features
»» Mounts to front of AccuLoad N4 or Split
Architecture MMI for Division II approved areas
»» LED (red, green, yellow), buzzer, and relay,
all of which can be controlled remotely by an
automation system
»» Interfaces directly with AccuLoad or the
automation system Specifications
»» Card authorization valid until programmable
Electrical Inputs
timeout expires (1-99 minutes)
DC Instrument Power:
»» Uses serial communications port (EIA-232 /
24 Vdc, 35 mA
485) and Smith protocol communications
12 Vdc, 70 mA
»» Available for N4 (Division II approved areas) or
hazardous locations (Division I approved areas) Electrical Outputs
DC Output:
Type: Optically-isolated solid state output.
Card Features User-programmable as to function.
»» Universal compatibility with HID Readers Polarity: Programmable (normally open or normally closed).*
»» External number for easy identification and control Switch Blocking Voltage: 30 Vdc maximum
»» Custom pre-printed artwork available Load Current: 150 mA maximum with 0.9 volt drop
»» Meets ISO standards for thickness (6 Ω typical)
»» Approved for hazardous locations operations Note: *Power-down normally open.
Card Interface
Excite Frequency: 125 kHz
Applications Typical Read Range: Within up to 2" (5.08 cm) of glass
PC IS
Model Designation
Proximity Card - PC
Printing
STD - Blank
CF - Custom Artwork
Intrinsically Safe
IS - Intrinsically Safe
7.6"
(193)
6.7"
(170)
6" .875"
(152) (22)
Diameter
4"
(102)
3"
(76 ) 2"
2" (51)
(51 )
2.125"
(53)
1.0"
(25)
1.3" 1.0"
(33 ) (25)
2.7" 1.7"
(67 ) (43) 3"
(76)
.312" (8)
Diameter
Typical 4 places
.5"
1.5" (13)
(38)
Note: Dimensions – Inches to the nearest tenth (millimetres to the nearest whole mm), each independently dimensioned from
respective engineering drawings.
4.0"
(102)
4.9"
(124)
3.2" 2.5"
4.5"
(81) (64)
(114)
5.7"
(145)
Note: Dimensions – Inches to the nearest tenth (millimetres to the nearest whole mm), each independently dimensioned from respective
engineering drawings.
The specifications contained herein are subject to change without notice and any user of said specifications should verify from the manufacturer that the specifications are currently in
effect. O
therwise, the manufacturer assumes no responsibility for the use of specifications which may have been changed and are no longer in effect.
Contact information is subject to change. For the most current contact information, visit our website at www.fmctechnologies.com/measurementsolutions and click on the “Contact Us” link
in the left-hand column.
USA Operation
1602 Wagner Avenue
Erie, Pennsylvania 16510 USA
TechnipFMC P:+1 814.898.5000
FMC Technologies
Measurement Solutions, Inc. Germany Operation
500 North Sam Houston Parkway West, Smith Meter GmbH
TechnipFMC.com Suite 100 Regentstrasse 1
Houston, Texas 77067 USA 25474 Ellerbek, Germany
© TechnipFMC 2017 SSK06044 Issue/Rev. 0.6 (9/17) P:+1 281.260.2190 P:+49 4101 304.0