Professional Documents
Culture Documents
Chemical Composition Raw Material Grade: Metso Outotec India Private Limited
Chemical Composition Raw Material Grade: Metso Outotec India Private Limited
No JSPL/ANGUL/TDC-004976A
TECHNICAL DELIVERY CONDITIONS
Rev. 1
TSD-PLATE DIVISION FOR HOT ROLLED PLATES
ANGUL-ODISHA(INDIA) Date of Issue 20/07/2023
Customer Name : METSO OUTOTEC INDIA PRIVATE LIMITED
Chemical Remarks
CE(IIW) = C+Mn/6+(Cr+Mo+V)/5 +(Ni+Cu)/15
7
Mechanical Properties
Elongation (%) Thick (mm) Bend Test (180°)
Thick (mm) YS (MPa) UTS (MPa)
(min) Internal
Sample
Sample GL=5.65 So Min Max Mandrel
Min Max Min Min Orientation
Orientation (mm) Diameter
8 19.99 T 250 410 23 8 25 T 2t
20 40 T 240 410 23 40.01 150 T 3t
40.01 150 T 230 410 23
CVN Impact Test
Temp Energy (J) Energy (J) Sample
(°C ) (minimum individual) (minimum average) Orientation
25 19 27 L
8
Test Sample Frequency in as supplied condition
Tensile Bend Impact
2 samples per 2 samples per 1 sample per
heat heat heat
9
Other Details
Dimensional Tolerance
TolThickness (mm) TolLength Edge Condition
i.Customer shall trim plate edges up to 1.5 X thickness or 40 mm, whichever is maximum, on each edge of the plates.
ii. Width Tolerance for plates with Mill edge condition
iii. JSPL will not do grinding near the plate edges (refer point i) for any surface imperfections.
iv. Customer / Customer's Representative will not hold any plate if any defect is observed near the edges (refer point i).
Maximum 0.2% of the actual length Maximum 1% of the actual width As per EN 10029 Class N Type L
Plate Inspection
Ultrasonic Inspection Visual Inspection
EN10160 S1E1
Surface quality: As per IS 2062 Clause 7.1 and 7.2. Repair by
Inspection will be carried out from one Major Surface of the plate, welding shall not be done.
preferably from Top Surface only.
9
Plate Marking
Stencil Marking Hard Punching
Manufacture's Name Yes
Heat No. /Plate No. Yes Yes
Grade/Specification Yes Yes
Size (Thickness x Width x Length) (in mm) Yes
UT Level Yes
Stenciling + hard punching shall be done on top surface of the plate at one end.
11
Inspection Agency
By JSPL
12
Remarks
1.Any handwritten modification / comment in this document will make this document invalid and shall need reconfirmation from Plant.
2. Steel is a technical product and any guarantee regarding the end application shall not come under JSP's obligations. JSP shall fulfill the properties as
defined in this TDC only.
Initiator Approved By
Jain Date: 2023.08.21 08:44:48
+05'30'
Customer Approved
Prepared By Reviewed By Section incharge(TSD) (Seal & Signature)