Professional Documents
Culture Documents
Infinity Kappa Series User Manual
Infinity Kappa Series User Manual
Infinity Kappa Series User Manual
1t
INSTRUCTIONS
®
K APPA S ERIES
-2-
A NOTE ON POWER HANDLING GENERAL CARE SPECIFICATIONS
The Kappa 10.1t tweeters are designed to The loudspeaker grilles may be cleaned with a
produce reasonable volume levels with little slightly damp cloth. Do not use any cleaners or 10.1t
amplifier power. However, the addition of solvents on the grilles or the speaker drivers. Type: Component Tweeter
an amplifier to drive your speakers and a Speaker Impedance: 4 ohms
subwoofer will enhance the dynamic range Power Handling: 50 watts per channel
of your system, and help overcome the with crossover
ambient noise in a moving vehicle. Kappa Frequency
speakers are designed to handle the power Response (± 3dB): 8kHz ~ 22kHz
of a dedicated amplifier driven at or below Sensitivity: 89Hz @ 2.83 V, 1 watt
its rated power. If an amplifier is driven far Crossover Frequency: 8000Hz
above its rated power, the output signal will Cut-out Diameter Tweeter: 1-5/8" (42 mm)
“clip,” and the additional power present in a
clipped signal can damage any speaker.
Distorted or “fuzzy” sound from your
speakers is an indication that the amplifier
Figure 3. After the Kappa10.1t tweeter is in its cup, has exceeded its rated power, and you
hand tighten the nut to flush-mount the assembly on should reduce the volume level.
the panel.
DECLARATION OF CONFORMITY
-3-