Professional Documents
Culture Documents
Asms 2
Asms 2
- TREE TYPE
ASSEMBLY INSTRUCTIONS
1 2 3
Assemble Frame (ASMS2-01) and Attach Leg Support (ASMS2-03) to Assemble Wheels (ASMS2-09) on
Main Frame (ASMS2-02) as shown Frame (ASMS2-02) as shown both sides of frame (ASMS2-02). Add
in photo 1. in Photo 2. one flat washer, carter pin to each wheel
shaft and bend pin as shown in Photo 3.
6 7
PHOTO 6 PHOTO 7
Next, on the opposite side of the paper cutting blades, installs two Because the paper cutting blades have sharp
paper roller assemblies on each support bar as shown in Photos 6. edges, we have saved their installation for last.
Always be careful when handling these cutting
blades. Start at the lowest 22" Support as
In Sequence, plastic slide ring, washer, spring, washer and slide ring, shown in photo 7 and install one cutting blade
Tighten the slide ring screws when you decide on the best spacing to and spring on each of the four frame supports,
suit your needs 22" (ASMS2-29) and 16" (ASMS2-28).
CAUTION!! Do not over tighten screws as
the plastic threads can strip.
Page 2